Multiquip HHN34TVD - Manual (Page 26)

page 26 — HHN34TVD RIDe-ON TROWeL • OpeRaTION maNuaL — ReV. #2 (01/10/11)
Maintenance
eNgINe OIL aND FILTeR
1. Change the engine oil and filter after the first 5 hours
of use, then change oil every 6 months or 150 hours.
2. Remove the oil filler cap (Figure 5), and fill engine
crankcase with recommended type oil as listed in Table
4. Fill to the upper limit of dipstick.
3. Crankcase oil capacity with oil filter replacement is
6.72 qts. (7.4 liters).
Oil Filter (300 Hours)
1. Replace the engine oil filter (Figure 13) every other oil
change or 300 hours. Refer to your engine manual for
specific details to perform this operation.
Figure 13. Oil Filter
2. Be sure to coat the seal of the new oil filter with clean
engine oil.
FueL FILTeR
Replace the engine fuel filter (Figure 14) every 800 hours.
Refer to your engine manual for specific details to perform
this operation.
SEAL
Table 4. Recommended Viscosity grades
F
C
TEMPERATURE RANGE EXPECTED BEFORE NEXT OIL CHANGE
-20 0 20
10W-30, 10W-40, 10W-50
30
32 40 60 80 100
-30 -20 -10 0 10 20 30 40
5W-30
Figure 14. Fuel Filter
OIL/WaTeR SepaRaTOR
Drain water from the bottom of the fuel filter by loosening the
drain plug and allowing the water to drain out. Refer to your
engine manual for specific details to perform this operation.
OIL aND FueL LINeS
„ Check the oil and fuel lines and connections regularly
for leaks or damage. Repair or replace as necessary.
„ Replace the oil and fuel lines every two years to maintain
the line's performance and flexibility.
RaDIaTOR/COOLINg SySTem
1. Check and clean radiator fins.
2. Check cooling water.
3. Check radiator hoses for fatigue or cracking.
4. Check radiator cap seal.
Refer to your engine manual for additional information.
PRIMING
PUMP
FUEL
FILTER
DRAIN
PLUG
O-RING
SENSOR
WIRE
WaRNINg
Hot coolant can cause severe burns.
DO NOT remove cap if radiator is HOT.