Multiquip WRS5200 - Manual (Page 13)

WRS 5200 RIDE-ON ROLLER SCREED — PARTS MANUAL— REV. 1# (08/09/02) — PAGE 13
Lifting the Screed and Power unit
MAINTENANCE SAFETY
■ Disconnect the battery and spark plug wires before attempting
any type of service.
■ Securely support any machine components that must be
raised.
■ NEVER lubricate components or attempt service on a running
machine.
■ Allow the machine a proper amount of time to cool before
servicing.
■ Keep the machinery in proper running condition.
■ Make sure that there is no buildup of concrete, grease, oil or
debris on the machine.
■ Fix damage to the machine immediately and always replace
broken parts.
■ Dispose of hazardous waste properly. Examples of potentially
hazardous waste are used motor oil, fuel and fuel filters.
■ DO NOT use food or plastic containers to dispose of
hazardous waste.
■ DO NOT pour waste, oil or fuel directly onto the ground,
down a drain or into any water source.
The following safety guidelines should always be used when
operating the WRS-5200 Screed:
GENERAL SAFETY
■ DO NOT operate this equipment unless all guards and safety
devices are attached and in place.
■ Use proper heavy lifting techniques when moving equipment.
This screed is very heavy. It should be lifted only with a lifting
device (i.e. crane, forklift, etc.) with a lifting capacity of at least
one ton.
■ Check to make sure that the operating area is clear before
starting the engine.
■ ALWAYS have
throttle at idle position while starting the
engine.
■ ALWAYS keep clear of rotating or moving parts while
operating this equipment.
■ NEVER leave the machine unattended while running.
■ Refuel in a well-ventilated area, away from sparks and open
flames.
■ Moving Parts - Shut down the engine and disconnect battery
before performing service or maintenance functions. Contact
with moving parts can cause serious injury.
■ Unauthorized equipment modifications will void all
warranties.
■ Disconnect battery and spark plug wires before attempting
service.
CAUTION CAUTION CAUTION CAUTION CAUTION:
Temperatures
■ High Temperatures – Allow the machine
and engine to cool before adding fuel or
performing service and maintenance functions.
Contact with
hot components can cause
serious burns.
Emergencies
■ Always know the location of the nearest
fire
extinguisher and first aid kit . Know the
location of the nearest telephone. Also know
the phone numbers of the nearest
ambulance ,
doctor and fire department . This information
will be invaluable in the case of an emergency.
CAUTION CAUTION CAUTION CAUTION CAUTION:
■ Use straps of adequate lifting capacity to lift the drive roller
and strike tube.
■ To lift the power unit, attach a crane or lifting device of
adequate lifting capacity to the power unit's lifting bail.
■ When lifting of the screed or power unit is
required, NEVER stand underneath the
screed or power unit The possibility exist that
severe bodily harm or even death may occur.
DANGER DANGER DANGER DANGER DANGER:
WRS-5200 — RULES FOR SAFE OPERATION