JLG X390AJ Operator Manual - Manual (Page 8)

TABLE OF CONTENTS
ii – JLG Lift – 3128792
SECTION - PARAGRAPH, SUBJECT PAGE SECTION - PARAGRAPH, SUBJECT PAGE
Electric Engine Starting Procedure -
LITHIUM-ION Machine . . . . . . . . . . . . . . . . . . . . .4-5
4.4 BASE AND BOOM/JIB ALIGNMENT . . . . . . . . . . . .4-6
4.5 TRACKS - DRIVING, STEERING AND
TRACK WIDTH ADJUST . . . . . . . . . . . . . . . . . . . . .4-7
Travelling (Drive and Steer) . . . . . . . . . . . . . . . . .4-7
Travelling (Grades and Side Slopes) . . . . . . . . . .4-7
4.6 OUTRIGGER OPERATION. . . . . . . . . . . . . . . . . . . .4-9
Setting Outriggers From the Platform/Remote
Console . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-10
Retracting The Outriggers . . . . . . . . . . . . . . . . .4-12
4.7 BOOM/PLATFORM OPERATION. . . . . . . . . . . . . .4-13
Overload Alarm . . . . . . . . . . . . . . . . . . . . . . . . . .4-13
Platform Level Adjustment . . . . . . . . . . . . . . . . .4-13
Raise And Lower The Tower Boom . . . . . . . . . .4-15
Raise And Lower The Main Boom . . . . . . . . . . .4-15
Telescope The Main Boom. . . . . . . . . . . . . . . . .4-15
Raise And Lower The Jib . . . . . . . . . . . . . . . . . .4-15
Emergency Lowering . . . . . . . . . . . . . . . . . . . . .4-17
Platform Removal/Installation . . . . . . . . . . . . . . .4-17
4.8 BATTERY CHARGING -
GAS/DIESEL/AC-ELECTRIC . . . . . . . . . . . . . . . . .4-18
Battery Charging - Daily . . . . . . . . . . . . . . . . . . .4-18
4.9 BATTERY CHARGING - LITHIUM-ION MACHINE .4-19
Charging the Battery Pack . . . . . . . . . . . . . . . . .4-20
Charge Curve . . . . . . . . . . . . . . . . . . . . . . . . . . .4-21
4.10 SHUT DOWN AND PARK. . . . . . . . . . . . . . . . . . . .4-22
4.11 LIFTING AND TIE DOWN . . . . . . . . . . . . . . . . . . . 4-23
Lifting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-23
Tie Down. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-24
4.12 MACHINE DECALS . . . . . . . . . . . . . . . . . . . . . . . . 4-26
SECTION - 5 - EMERGENCY PROCEDURES
5.1 GENERAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-1
5.2 INCIDENT NOTIFICATION . . . . . . . . . . . . . . . . . . . 5-1
5.3 EMERGENCY OPERATION . . . . . . . . . . . . . . . . . . 5-1
Power Main Cut-Off Switch Location . . . . . . . . . . 5-1
Operator Unable to Control Machine. . . . . . . . . . 5-2
Platform or Boom Caught Overhead . . . . . . . . . . 5-2
Manual Descent with Engine Running and
Electrical Power . . . . . . . . . . . . . . . . . . . . . . . . . . 5-2
Manual Descent with Engine Running but without
Electrical Power (Combustion Engine Only) . . . . 5-6
Manual Descent without Engine and
Electrical Power . . . . . . . . . . . . . . . . . . . . . . . . . . 5-7
Outrigger/Track Movement Emergency
Procedure. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-10
5.4 SAFETY DEVICES BYPASS KEY USE . . . . . . . . . 5-13
Using The Emergency Descent In The Case Of
An Outrigger Losing Contact With The Ground. 5-14
Machine Realignment Emergency Procedure. . 5-15
5.5 LITHIUM-ION BATTERY PACK - HANDLING IN
DANGEROUS CONDITIONS. . . . . . . . . . . . . . . . . 5-17
Procedure For Handling Hot Cells. . . . . . . . . . . 5-17