Baja Marine JAY SERIES YEAR 2006 - Manual (Page 19)

WARRANTY REGISTRATION AND CUSTOMER DELIVERY FORM
Dealer is to assure that this form is properly completed and returned to Jayco within ten (10) working days after delivery.
OWNER’S NAME DEALER’S NAME
ADDRESS ADDRESS
CITY STATE ZIP CODE CITY STATE ZIP CODE
DELIVERY DATE PHONE NUMBER (DAYTIME) ODOMETER READING (MUST BE COMPLETED FOR MOTORHOMES)
JAYCO SERIAL NUMBER CHASSIS VIN (VEHICLE I.D. NUMBER) (SEVENTEEN DIGITS REQUIRED)
DEALER INSTALLED OPTIONS (Dealer installed options are not covered under Jayco’s limited warranties.)
OWNER/DEALER INSPECTION
I HAVE COMPLETED THE ABOVE INSPECTION ON THIS FAMILY CAMPING VEHICLE AND HAVE TAKEN A TEST DRIVE AT THE TIME OF
PURCHASE. I NOTED:
I RECEIVED A COPY OF THE JAYCO LIMITED WARRANTY BEFORE I PURCHASED THIS VEHICLE AND I UNDERSTAND THAT IT IS
DESIGNED TO BE USED ONLY FOR RECREATIONAL CAMPING AND TRAVEL.
THE PURCHASER HAS INSPECTED OR BEEN GIVEN THE OPPORTUNITY TO INSPECT THE VEHICLE AND TAKE THE TEST DRIVE,
SUPPLIED THE INFORMATION ABOUT HIS/HER NAME AND ADDRESS, BEEN GIVEN THE OPPORTUNITY TO MAKE NOTATIONS IN
THE SPACE PROVIDED AND OBSERVED OR RECEIVED SATISFACTORY EXPLANATIONS ABOUT ALL ITEMS LISTED ABOVE.
DATE PURCHASER’S SIGNATURE DEALER’S SIGNATURE
Jay Series/Baja/Select Folding Camping Trailer 9
Warranty/Service
SA
MP
LE
Jayco, Inc.
P.O. Box 460
903 South Main Street
Middlebury, IN 46540
(574) 825-0608
ALL ITEMS MUST BE MARKED OFF BY THE DEALER IN THE CUSTOMER’S PRESENCE INDICATING
PERFORMANCE OR INSTRUCTION AS REQUIRED.
PLEASE MARK EACH ITEM OK OR NA (NOT APPLICABLE).
1. ELECTRICAL SYSTEM
¾
120-Volt System
¾
120-Volt Auxiliary Generator Operation
¾
12-Volt System
¾
Ground Fault Circuit Interrupter (GFCI)
¾
All Interior Lights/Recepts/Switches
¾
All Exterior Lights/Recepts/Switches
¾
Battery System
¾
Monitor Panel
¾
Slideout Operation and Maintenance
¾
Phone and Cable TV
¾
Audio/Video Entertainment System
¾
Converter Operation and Use
¾
Solar Panel
¾
Interior Fans - All
a. Motorized Only
¾
Inverter Operation and Use
¾
Driver Dash Controls/Switches
¾
Hydraulic Leveling Jacks
¾
Power Cord/Reel
¾
Backup Camera and Monitor
2. PROPANE SYSTEM
¾
Location and Maintenance of Propane
Lines and Connections
¾
Maintenance and Operation of Regulator
¾
Propane Monometer Test (Check for leaks -
repair if needed and retest) Set Pressure at
________in. Water Column
¾
Outside Grill Use and Operation
3. WATER/PLUMBING SYSTEM
¾
Water Intake/Drain Lines
¾
Demand Pump
¾
Faucet(s)/Fixture(s)
¾
Winterizing/Bypass
¾
Outside Shower
¾
Shower
3. WATER/PLUMBING SYSTEM CONT.
¾
Black Holding Tank(s)
¾
Grey Holding Tank(s)
¾
Fresh Water Holding Tanks(s)
¾
Toilet
4. APPLIANCES
¾
Furnace and Thermostat
¾
Range/Oven/Hotplate
¾
Water Heater
¾
Refrigerator
¾
Air Conditioner
¾
Microwave
¾
Central Vacuum
¾
Heat Pump
¾
Washer/Dryer
5. INTERIOR
¾
Curtain/Drapes/Valances/Blinds
¾
Beds/Couches/Tables
¾
Fire Extinguisher (Check CHARGE ONLY)
¾
Interior Trim and Sealants
¾
Windows - Crank Mechanisms/Slides/etc.
6. EXTERIOR
¾
Doors and Locks - all keys
¾
Screen Door
¾
Entrance Step
¾
Finish - spot paint, touch up and rub out if
necessary
¾
TV and/or Satellite Antenna Mechanism
¾
Vents - all
¾
Compartment Doors
¾
Trim and Sealants
¾
Awnings
¾
Bumper/A-Frame - touch up as needed
¾
Window and Roof Sealants
7. CHASSIS - MOTORIZED ONLY
¾
Check all Fluid Levels
¾
Chassis Prep as Recommended by the
Manufacturer
¾
Tires - Condition and Pressure
¾
Wheel Lugs - as outlined in Chassis manual
8. RUNNING GEAR - TOWABLE ONLY
¾
Brake Adjustment and Maintenance
¾
Bearing Lubrication and Maintenance
¾
Brake Wire Connections
¾
Hydraulic Brake Fluid and Maintenance
¾
A-Frame/Coupler Operation
¾
Operate and Lube Jacks
¾
Tires - Condition and Pressure Set
Tire Pressure ________ psi
¾
Wheel Lugs - (Tighten to specs for ft. lb.
torque) Review Maintenance - tighten at
10,25,50 miles
9. FOLDING CAMPING TRAILER ONLY
¾
Complete Set Up and Closing
Demonstration, Proper Leveling
10. GENERAL
¾
Wash Vehicle
¾
Be certain that all required literature is in the
vehicle
¾
Be certain that all accessories including
remotes are in the vehicle
¾
Be certain that all Owner’s Manuals are in
the vehicle
¾
Be certain that the Warranty Forms are
completed
1. Exterior and interior finish.
2. Operate all appliances, optional equipment and accessories and discuss
maintenance.
3. Review operation, maintenance and safety of Propane System.
4. Explain weight ratings, limitations and proper load distribution and
maintenance.
5. Operate all fresh water and plumbing components including faucets, shower,
toilet and drain locations.
6. Review tow vehicle, hitch and sway control set-up - test drive. (towables only)
7. Complete review of owner’s manuals and highlight safety issues.