Baja Marine JAY SERIES YEAR 2006 - Manual (Page 103)

Monthly
0
Clean and lubricate the coupler.
0
Check fire extinguisher pressure. Refer to the fire extinguisher label for specific
instructions.
0
Test the ground fault circuit interrupter (GFCI)
Every Three Months or 3,000 Miles
0
Compare water heater pilot flame with ideal flame. Refer to the water heater owner’s
manual for ideal flame. Have cleaned and adjusted as necessary by a qualified
technician.
0
Compare refrigerator pilot flame with ideal flame. Refer to the refrigerator owner’s
manual for ideal flame. Have cleaned and adjusted as necessary by a qualified
technician. (RV type refrigerator only)
0
Inspect refrigerator door seals.
0
Inspect refrigerator combustion seals. Have cleaned and adjusted as necessary by a
qualified technician. (RV type refrigerator only)
0
Check propane lines for leaks.
0
Inspect propane cylinders for rust, pits, gouges, scrapes or sharp dents. Repaint
cylinders if rust is present.
0
Drain and sanitize fresh water system.
0
Check, clean, tighten and lubricate battery cables.
0
Check wheel nuts at specified intervals to listed torque values. Re-torque as needed.
Refer to the axle manufacturer’s manual.
0
Examine the tires for unusual wear, sidewall defects from possible cuts, bulging and
abrasions.
0
Lubricate tongue jack.
0
Lubricate hitch ball.
0
Have brakes adjusted by a qualified service technician.
Every Six Months or 6,000 Miles
0
Clean drains with approved drain cleaners.
0
Check pipe connections for tightness. Tighten if necessary.
0
Lubricate all moving parts on the entrance steps.
0
Lubricate entrance and baggage door locks.
0
Clean and lubricate stabilizer jacks.
0
Inspect wheels for cracks, dents or distortion.
0
Inspect and reseal your trailer as defined earlier in this chapter.
0
Have suspension system serviced by a qualified service technician.
0
Perform routine preventative maintenance on entire trailer and all component parts.
Jay Series/Baja/Select Folding Camping Trailer 93
Maintaining Your Investment...