Prochem Everest 408-650, LP-HP - Manual (Page 9)

7
Safety
Before disconnecting the negative (-) ground cable, make sure all switches are OFF. If ON, a spark will occur at the
ground cable terminal which could cause an explosion if hydrogen gas or gasoline vapors are present. When
disconnecting the battery, ALWAYS disconnect the negative (-) terminal FIRST.
DO NOT smoke around the unit. Gas fumes may accumulate and be ignited. The battery is also extremely
flammable. This will prevent possible explosions.
DO NOT damage the vehicle in any manner during installation. When routing fuel lines DO NOT place the hose in
any location where damage may occur to the hose or vehicle. Avoid any contact with moving parts, areas of high
temperature, brake lines, fuel lines, muffler, catalytic converter, or sharp objects.
DO NOT cut or splice any of the vehicle fuel lines during fuel line installation. This may result in fuel leaks and
potentially dangerous conditions. There is no fuel solenoid shut off on this unit. Use only the provided fuel hose for
fuel lines. When traversing the vehicle floor with fuel lines, always use a bulkhead adapter. This will prevent leakage
and ensure that the hose is not punctured by vehicle vibration abrasion.
DO NOT exceed your vehicle's weight limit: The console with empty 100 gallon waste tank and accessories weighs
approximately 1300 lbs. Make certain to account for any additional accessories in your weight and balance
calculations. Make certain that the vehicle has the correct axle rating, to prevent unsafe vehicle driving conditions.
We require high-back seats on all vehicles in which units are to be installed for head and neck protection. We
recommend using a metal partition between the seats and equipment.
DO NOT operate this unit without the water supply attached and turned on. The solution pump and other vital
components may be seriously damaged if this unit is permitted to operate dry without water. Running with out
adequate water supply could damage solution pump. Ensure always to have an adequate water supply.
DO NOT operate this unit without the filter installed in the waste tank.
Keep your vehicle work area clean. Wands, stair tools, and other accessories must be securely fastened before
driving the vehicle.
All high pressure hoses must be rated for 3000 PSI at 250°F. Thermoplastic hoses do not meet these specifications
and should not be used. Severe burns and injury may result if the hoses do not meet these requirements. Pressure
wash hoses must be rated at 4000 PSI.
The winterizing loop hose assembly, is for winterizing use only. If used improperly, live steam may escape from this
hose, causing it to whip around. Burns or injury may result.
Make certain that you receive complete training by the distributor from whom you purchased this unit.
This unit uses high pressure and temperature. Improper or irresponsible use may result in serious injury.
Do not modify this unit in any manner. Improper modification can cause severe personal injury or fatality.
CALIFORNIA PROPOSITION 65 WARNING: Engine exhaust from this product contains chemicals known to the
State of California to cause cancer, birth defects, or other reproductive harm.
86352170 EVEREST