HTP PHE199-119S - Manual (Page 26)

26
LP- 204 REV. 3.25.14
NATURE OF TROUBLE POSSIBLE CAUSE SERVICE
No hot water 1. Improper wiring Rewire per Wiring Diagram
2. No power – blown fuse or circuit breaker
tripped
a. Shorted wiring
b. Circuit overloaded
c. Improper wiring
a. Repair
b. Provide adequate circuit or reduce load
c. Rewire
3. Solar system incorrectly installed Check installation
4. Leaking plumbing or open hot water
faucet(s) Make sure all faucet(s) are closed and check water
meter
Not enough hot water 1. Heater undersized Reduce rate of hot water use
2. Wired incorrectly Check wiring or replace
3. Solar system incorrectly installed Check installation
Water too hot or not hot
enough 1. Setting too high or low Change setting as required
2. Solar system incorrectly installed Check installation
Table 3
See water heater installation manuals for more detailed maintenance information.
PART 11 - SYSTEM PARTS LISTING
A. ESTIMATED COMPONENT LIFE
When installed and maintained as directed by this manual, one can expect many years of trouble-free service from this solar system.
However, all components in this system are subject to installation conditions. For example: Where hard water is present, mineral
deposits can shorten the life of components. Periodic maintenance as prescribed by this manual ensures that these components are
well protected from such damage.
B. WARRANTIES AND DISCLAIMERS
NOTE: WE EXCLUDE ANY WARRANTY FOR, OR LIABILITY FROM ACTS OF NATURE, INCLUDING FREEZE DAMAGE.
Warranty periods for tank components are listed in the table below:
MANUFACTURER ITEM PART#
COMPONENT
COVERAGE
TANK
COVERAGE
HTP
Stainless Steel Solar Water Heater
w/ Gas-Fired Back-Up
PH130-80S 1 year
Residential – 7 years
Commercial – 3 years
HTP
Stainless Steel Solar Water Heater
w/ Gas-Fired Back-Up
PH130-119S 1 year
Residential – 7 years
Commercial – 3 years
HTP
Stainless Steel Solar Water Heater
w/ Gas-Fired Back-Up
PH199-80S 1 year
Residential – 7 years
Commercial – 3 years
HTP
Stainless Steel Solar Water Heater
w/ Gas-Fired Back-Up
PH199-119S 1 year
Residential – 7 years
Commercial – 3 years
HTP
Stainless Steel Solar Water Heater
w/ Gas-Fired Back-Up
PHE130-80S 1 year
Residential – 12 years
Commercial – 5 years
HTP
Stainless Steel Solar Water Heater
w/ Gas-Fired Back-Up
PHE130-119S 1 year
Residential – 12 years
Commercial – 5 years
HTP
Stainless Steel Solar Water Heater
w/ Gas-Fired Back-Up
PHE199-80S 1 year
Residential – 12 years
Commercial – 5 years
HTP
Stainless Steel Solar Water Heater
w/ Gas-Fired Back-Up
PHE199-119S 1 year
Residential – 12 years
Commercial – 5 years
Table 4