Warning – Daystar KN09105 User Manual

Page 2

KN09105 – 2005-2012 Nissan Xterra/Frontier 2" Lift

Instruction Sheet - P11074-02

Page 2 of 2

www.DaystarWeb.com

Tech Support:

[email protected]

Phone: 623.907.0081 / Fax: 623.907.0088

841 South 71

Avenue; Phoenix, AZ 85043

Rear Installation

14. Remove spare tire.
15. Raise vehicle until rear tires are clear, support the vehicle.
16. Remove rear sway-bar bolt and swing the bar and linkage out of the way. Remove the shocks.
17. Support the rear axle and remove the OE shackles and OE spring bushings.
18. Install new Daystar Greaseable shackles. See Fig 2.
19. Reconnect the sway bar and install optional new shocks (22in. extend length, 13.5 compressed

Eyelet/Eyelet)

20. Torque all bolts to factory specs and check after 50 miles.
21. After installation of kit; alignment should be checked and adjusted if necessary.

IMPORTANT NOTE: The advertised amount of lift that this kit provides

and the thickness of the spacers supplied will not be the same! For

example, a 2-1/2” lift may only have 1-1/2” thick spacers. The reason for
the difference between the spacer thickness and the amount of lift has to

do with suspension geometry. There is a ratio involved, and it is this ratio

that determines the thickness of the spacers. Rest assured, installing the

spacer supplied will result in the proper amount of lift out at the wheel.

WARNING

This vehicle has been modified to enhance its performance.

The steering, braking and handling of this vehicle will differ
from standard passenger cars and trucks. This vehicle
handles differently from an ordinary vehicle in driving
conditions which may occur on streets, highways and off road.

Avoid unnecessary abrupt maneuvers, sudden stops, sharp

turns and other driving conditions that could cause loss of
control, possibly leading to a roll over or other accident that
could result in serious injury or death to driver and passengers.

If larger tires are installed the speedometer will read lower

than the vehicles actual speed.

DRIVE WITH CARE, REDUCE SPEED

AND WEAR SEAT BELTS AT ALL TIMES.

This kit should be installed by a professional mechanic.