Banks Power Chevy_GMC Trucks: Duramax LB7 (Diesel ’01 - 04 6.6L) Power Systems- PowerPack & Stinger Systems w_ EconoMind (LB7 & LLY) '01-05 (PDA) Compatible w_ Optional PowerPDA User Manual
Page 3
Tools Required:
•
1
⁄
4
” and
3
⁄
8
” drive ratchets
• Inch and metric deep sockets
• Ratchet extension
• Metric combination or open-end
wrenches
• Phillips and flat blade screwdrivers
• Standard and needle-nose pliers
• Pocket or X-Acto knife
• Clean shop towels or rags
• Drill bit set
• Drill motor
• Tap Handle
•
1
⁄
4
” NPT tap
•
5
⁄
16
nut driver
• Pliers
• Torx bits
• Pry-bar
Highly recommended tools and
supplies:
• Multimeter or 12-volt test light
• Heat gun
• Foot-pound torque wrench
• Penetrating oil or light lubricant
spray
• Reciprocating saw
• Inch-pound torque wrench
Table of Contents
General Assembly Diagram . . . . . . 4
Banks Power Pack System
Section 1 . . . . . . . . . . . . . . . . . . . . . . 6
Installation of Banks Monster Exhaust
System
Section 2 . . . . . . . . . . . . . . . . . . . . . 13
Techni-cooler Assembly Installation
Section 3 . . . . . . . . . . . . . . . . . . . . . 24
Thermocouple Installation
Section 4 . . . . . . . . . . . . . . . . . . . . . 25
Banks Ram-Air Intake System
Section 5 . . . . . . . . . . . . . . . . . . . . . 31
Banks EconoMind Diesel Tuner
Installation
Section 6 . . . . . . . . . . . . . . . . . . . . . 33
Mounting the Docking Station and
connecting the Banks PowerPDA Vehicle
command center
Section 7 . . . . . . . . . . . . . . . . . . . . . 35
Installation of the Power Level Selector
Switch
Section 8 . . . . . . . . . . . . . . . . . . . . . 38
Optional Gauge cluster Installation
Section 9 . . . . . . . . . . . . . . . . . . . . . 39
Automatic Transmission Learning
Section 10 . . . . . . . . . . . . . . . . . . . . 40
Troubleshooting, EconoMind
Section 11 . . . . . . . . . . . . . . . . . . . . 42
clearing Learned Parameters
Section 12 . . . . . . . . . . . . . . . . . . . . 42
Updating Your Banks PowerPDA Software
& Banks EconoMind Diesel Tuner
Firmware
Section 13 . . . . . . . . . . . . . . . . . . . . 42
Removal of the EconoMind Diesel Tuner
Section 14 . . . . . . . . . . . . . . . . . . . . 43
Filter Maintenance
Section 15 . . . . . . . . . . . . . . . . . . . . 44
Placement of the Banks Power Decals
96776 v.11.0
3