MMD Equipment IGR1000 - Manual (Page 22)

MMD PowerPro Inverter Generators • IGR1000P • IGR2000P • IGR2600HP (041715) MMD PowerPro Inverter Generators • IGR1000P • IGR2000P • IGR2600HP (041715) Page 42 Page 43
11. Troubleshooting
Engine will not start
Problem/Possible cause Corrective action
No fuel in tank Refuel with gasoline
Engine switch not on Turn engine switch to ON position
Not enough oil in engine Refill with recommended oil
No spark from spark plug Check spark plug or replace spark plug
How to check spark plug:
1. Remove spark plug cap and clean any debris off sparkplug.
2. Remove spark plug and install spark plug in the plug cap.
3. Set the plug-side electrode on the cylinder head to the ground.
4. Pull the recoil starter. Sparks should jump across plug gap.
If the engine still does not start, please take the generator to an authorized dealer.
Appliance does not operate
Problem Corrective action
Output indicator not on Check appliance/equipment for defects
Overload indicator on 1. Replace appliance/equipment, or have repaired.
2. Stop and restart engine and try again.
If still not operational, please take the generator to an authorized dealer.
No power to the DC receptacle
Problem Corrective action
DC circuit fuse blown Replace fuse
If still not operational, please take the generator to an authorized dealer.
Make sure there is no spilled gasoline around spark plug. Spilled fuel may ignite.
12. Specifications
Model IGR1000P IGR2000P IGR2600HP
Rated Output, watts 900 1600 2300
Rated Current, amp 7.5 13.3 19.2
Maximum Output, watts 1000 2000 2600
Phase Single Single Single
Parallel operation allowed Yes Yes Yes
Maximum Current, amp 8.3 16.6 21.6
AC Voltage 120 120 120
Frequency, Hz 60 60 60
DC Output 12V @ 5A 12V @ 5A 12V @ 5A
HP @ rated RPM 1.74 @ 5500 2.95 @ 4500 4.4 @ 3600
Starting System Recoil Recoil Recoil
Engine Type
Air cooled, single cylinder, 4-stroke, OHV with
electronic ignition
Displacement, cc 53.5 105.6 171
Compression Ratio 8:5:1
Ignition System T.C.I.
Spark Plug UR5 UR5 F6RTC
Fuel
Regular unleaded automotive gasoline
(87-octane)
Lube Oil SAE 10W30 (see viscosity chart)
Oil Capacity - qt. (L) .2 (.2) .42 (.4) .63 (.6)
Noise Level, no load-full load, dB @ 23 ft. 54-59 54-59 58-65
Rated load continuous run time, hrs. 4 3.5 3
Fuel tank capacity, gal. (L) 0.7 (2.6) 1.0 (3.8) 1.32 (4.9)
Dimensions, LxWxH, in. 17.5 x 9.5 x 14.7
20 x 11
x 16.75
23.22 x 12.99
x 18.89
Dry Weight, lb. 30.8 48.5 68
Tune Up Specifications
Spark Plug Gap 0.024-0.028 in. (0.6-0.7 mm)
Valve Clearance (Intake) 0.0031-0.0039 in. (0.18-0.10 mm)
Valve Clearance (Exhaust) 0.0039-0.0059 in. (0.10-0.15 mm)