Polaris 2008 Ranger Crew - Manual (Page 67)

64
MAINTENANCE
Periodic Maintenance Chart
X Perform these procedures more often for vehicles subjected to severe use.
E Emission Control System Service - 4 Cycle (California).
Q
Have an authorized Polaris dealer perform these services
Item Maintenance Interval
(whichever comes first)
Remarks
Hours Calendar Miles
(Km)
Q
E
Fuel system 100 H 12 M - Check for leaks at tank cap,
lines, fuel valve, filter, pump,
throttle body; replace lines
every two years
Q Fuel filter (if exter-
nal to tank)
100 H 12 M - Replace yearly
X Radiator
(in applicable)
100 H 12 M - Inspect; clean external
surfaces
X Cooling Hoses 100 H 12 M - Inspect for leaks
X Engine mounts 100 H 12 M - Inspect
Exhaust muffler/
pipe
100 H 12 M - Inspect
X
E
Spark plug 100 H 12M - Inspect; replace as needed
Q
Ignition timing 100 H 12 M - Inspect
X Wiring 100 H 12 M - Inspect for wear, routing,
security; apply dielectric
grease to connectors
subjected to water, mud, etc.
Q
Clutches (drive
and driven)
100 H 12 M - Inspect; clean; replace worn
parts
Q
Front wheel
bearings
100 H 12 M - Inspect; replace as needed
Q
Brake fluid 200 H 24 M - Change every two years
Spark arrestor 300 H 36 M - Clean out
Idle speed - Adjust as needed
Q
Toe adjustment - Inspect periodically; adjust
when parts are replaced
Q
X
Auxiliary brake (if
equipped)
- Inspect daily; adjust as
needed
Headlight aim - Adjust as needed