Belshaw Adamatic EP18-24 Proofer - Manual (Page 9)

Belshaw Bros., Inc. • www.belshaw.com • Phone 206-322-5474 • Fax 206-322-5425
EP18/24/34 Econo Proofer OM MN-1202EN 3
3 Cleaning
Humidifier Water Box and
Reservoir
Once per day, clean the water box and reservoir
as follows:
1. Remove the water reservoir cover.
2. Mix an appropriate cleaner into the water box
and reservoir.
3. To break down lime scale, add 100-grain
vinegar.
4. Brush the heating elements and float
assembly to remove lime scale and sediment.
5. Remove water and cleaning solution.
6. Rinse thoroughly.
Proof Box
Once per week, clean the proof box as follows:
1. Remove and clean Plexiglas doors with
warm water.
2. Disconnect from power and remove control
box from cabinet.
3. Remove and clean the screen rack angles,
angle supports, and air duct.
4. Wipe the cabinet interior clean.
5. Special attention should be given to cleaning
the water box. Clean the water box as
follows:
A. Remove water reservoir cover.
B. Empty the water reservoir pan.
C. Remove water box access cover thumb
screw and rotate access cover to open
position.
D. Use a rubber syringe baster to remove
sediment from the water box. Wipe the
inside of the water box with a rag.
E. Add a small amount of water to the
water reservoir pan. Water should flow
freely into the water box. If not, clean
out the water line between the water box
and the water reservoir pan. Check for
blockage at the water box inlet hole first.
F. Close water box access cover and fasten
with thumbscrew.
G. Replace water reservoir cover.
Water Filtration System
Clean any water filtration system per the
manufacturer's instructions.
Following are some cleaning charts, to help keep track of regularly scheduled cleaning.