Delta PG PLUS-25 - Manual (Page 62)

56
Check-Out Procedures
SECTION XIII- Check-Out Pro c e d u re s
Perform the following check-out proce-
dures as outlined and check off items as
completed. When procedures are com-
pleted, the installer should complete the
installation record on page 57.
Check-out Procedures
 Both inner and outer tanks filled with
water.
 Water chemistry checked and verified
as outlined on page 47.
 The automatic air vent on the unit and
any place within the system are open
one full turn.
 Air is purged from the heating zones
and primary system.
 Domestic piping is purged of air and
has been checked for leaks.
 Burner has been confirmed as properly
configured for Propane application. (If
applicable).
 Thermostat circuit wiring checked and
verified that no voltage is present to the
Room Thermostat Snap-set as outlined
on page 50.
 Operating Instructions on page 52 were
followed during start-up.
 Combustion levels and flame pattern
verified as outlined on page 53.
 Measure the rate of input on Natural
Gas as outlined on page 53.
 Check the incoming gas pressure to
ensure a minimum pressure of 5”w.c
during flow conditions to all gas appli-
ances and a maximum pressure of
13”w.c during non-flow conditions for
natural and propane.
 Primary and Secondary T h e r m o s t a t
properly set as shown in Figure 38 and
39 page 54.
 The thermostatic mixing valve adjusted
to the desired domestic hot outlet tem-
perature.
 Adjusted balancing valves and system
limit controls to provide design temper-
atures to the primary space heating sys-
tem.
 In multiple zone applications, adjusted
for correct flow of primary heating
water to each zone.
 Check and verified room thermostat
function properly and the thermostat
heat anticipator (if used) was properly
set.
 Observed several operating cycles for
proper operation of the PERFOR-
MANCE PLUS and the system.
 Set the room thermostat(s) to the
desired room temperature.
 Reviewed all instructions shipped with
the PERFORMANCE PLUS with the
homeowner or maintenance personnel.
 Complete the Installation Record on
page 57.
 Ensure all manuals and other documen-
tation are returned to the Installation
envelope and given to the owner for
safekeeping.
NOTICE