Generac Power Systems GUARDIAN 04137-0 - Manual (Page 3)

SAFETY RULES
important Safety instructions
Guardian Llquid-cooied 8 kW Generators
A SAVE THESE INSTRUCTIONS - The manufacturer suggests that these rules for safe
operation be copied and posted in potential hazard areas. Safety should be stressed to all
operators and potential operators of this equipment.
Mm.
WARNING:
The engine exhaust from this product
contains chemicals known to the state
of California to cause cancer, birth
Study these SAf'ETY RULES carefully before
installing, operating or servicing this equipment.
Become familiar with this Oiuner's Manual and with
the unit. The generator can operate safely, effi­
ciently and reliably only If it is properly installed,
operated
and maintained. Many accidents are
caused by failing to follow simple and fundamental
rules or precautions.
Generac cannot possibly anticipate every possi­
ble circumstance that might involve a hazard. The
warnings in this manual, and on tags and decals
afffxed to the unit are, therefore, not all-inclusive. If
you use a procedure, work method or operating
technique Generac does not specificaJly recom­
mend, you must satisfy yourself that it is safe for
you and others. You also must make sure the pro­
cedure. work method or operating technique that
you choose does not render the generator unsafe.
-A0UE33 A-
A
A
Despite the safe design of this ' generator,
operating this equipment imprudently, neglecting
its maintenance or being careless can cause
possible injury or death. Permit only responsible
and capable persons to operate or maintain this
equipment.
Potentially lethal voltages are generated by
these machines. Ensure ai! steps are taken to
render the machine safe before attempting to
work on the generator.
Parts of the generator are rotating and/or hot
during operation. Exercise care near running
generators.
M GEIMERAL HAZARDS M
For safety reasons, Generac recommends
that the installation, inihal start-up and mainte­
nance of this equipment is carried out by a
Generac/Guardian Authorized Dealer.
The engine exhaust fumes contain carbon
monoxicTe, which can be DEADLY. This danger­
ous gas, If breathed in sufficient concenhations,
can cause unconsciousness or even death. This
exliaust system must be installed properly, in
strict compliance with applicable codes and stan­
dards. Following installation, you must do noth­
ing that might render the system unsafe or in
noncompliance with such codes and standards.
Keep hands, feet, clothing, etc., away from drive
belts, fans, and other moving or hot parts. Never
remove any drive belt or fan guard while the unit
is operating.
Adequate, unobstructed flow of cooling and venti­
lating air is critical to comect generator operation.
Do not alter the installation or permit even partial
blockage of ventilation provisions, as tliis can
seriously affect safe operation of the generator.
When working on this equipment, remain alert at
all times. Never work on the equipment when you
are physically or mentally fatigued.
Inspect the generator regularly, and repair or
replace all damaged or defective parts irrumedi-
ately. Always use factory-authorized parts.
Turn off the AC power to the batterv' charger
before disconnecting the battery to minimize the
chance of equipment damage.
Before performing any maintenance on the gen­
erator, disconnect Its battery cables to prevent
accidental start-up. Disconnect the cable from
tlie battery post indicated by a NEGATIYTD. NEG
or H first. Reconnect that cable last.
Never use the generator or any of its parts as a
step. Stepping on the unit can stress and break
parts, and may result in dangerous operating
conditions from leaking etdaaust gases, fuel leak­
age, oil leakage, etc.
Generac® Power Systems, Jnc.