Tjernlund CSA1 Chimney Stack Assist Kit 8504201 - Manual (Page 8)

5. Tripping of the Linear Limit Spillage Switch during the 5 minutes indicates an unsafe operating condition. Turn off fuel supply to
appliance and DO NOT OPERATE UNTIL UNSAFE VENTING CONDITION IS INVESTIGATED BY A PROFESSIONAL
CONTRACTOR OR UTILITY SERVICE PERSONNEL.
NOTE:
In rare cases the Linear Limit may trip the control circuit on this vent system due to excessive negative pressure in the dwelling, down
drafts, excessive water heater heat loss, etc. In these cases it may be necessary to add a Post Purge Timer Relay. This device will
operate the CSA1 after the water heater has shut off and purge the vent system of residual flue gases. Contact Tjernlund if a Post
Purge Timer Relay is desired.
6. Return all windows, doors and fans to their previous conditions of use.
7. Sign and date these instructions to verify that the Sign:
combustion air and safety interlock test have been
completed. These instructions must remain on premises.
Date:
HOW TO OBTAIN SERVICE ASSISTANCE
1. If you have any questions about the CSA1 or if it requires adjustment, repair or routine maintenance, we suggest that you con-
tact your installer, plumbing contractor or service agency.
2. If you require technical information contact Tjernlund Products, Inc. at 1-800-255-4208.
When contacting Tjernlund Products, Inc., please have the following information available:
1. Model number: CSA1
2. Name and address of installer and service agency
3. Date of original installation and dates any service work was performed
4. Details of the problem
LIMITED PARTS WARRANTY AND CLAIM PROCEDURE
Tjernlund Products, Inc. warrants the components of its products for one year from date of installation. This warranty covers defects in
material and workmanship. This warranty does not cover normal maintenance, transportation or installation charges for replacement
parts or any other service calls or repairs. Products that are tampered with, damaged, installed improperly, wired incorrectly or defec-
tive due to malfunctioning appliances are not covered under this warranty. This warranty DOES NOT cover the complete CSA1 if it is
operable; only the defective part.
1.) If unable to determine faulty component, contact your Tjernlund distributor or Tjernlund Products Technical Customer Service
Department at 1-800-255-4208 for troubleshooting assistance.
2.) After the faulty component is determined, return it to your Tjernlund distributor for replacement. Please include the job code
component was taken from. The job code is located on the Electrical Box coverplate. If the date code is older than 1 year, you
will need to provide a copy of the original installation receipt to your distributor. Credit or replacement will only be issued to a
Tjernlund distributor after the defective part has been returned prepaid to Tjernlund and verified defective.
7
TJERNLUND LIMITED ONE YEAR WARRANTY
Tjernlund Products, Inc. warrants to the original purchaser of this product that the product will be free from defects due to faulty material or workmanship for a period of (1)
year from the date of original purchase or delivery to the original purchaser, whichever is earlier. Remedies under this warranty are limited to repairing or replacing, at our
option, any product which shall, within the above stated warranty period, be returned to Tjernlund Products, Inc. at the address listed below, postage prepaid. THERE ARE
NO WARRANTIES WHICH EXTEND BEYOND THE DESCRIPTION ON THE FACE HEREOF, AND TJERNLUND PRODUCTS, INC. EXPRESSLY DISCLAIMS LIABILITY
FOR INCIDENTAL OR CONSEQUENTIAL DAMAGES ARISING FROM THE USE OF THIS PRODUCT. THIS WARRANTY IS IN LIEU OF ALL OTHER EXPRESS WAR-
RANTIES AND NO AGENT IS AUTHORIZED TO ASSUME FOR US ANY LIABILITY ADDITIONAL TO THOSE SET FORTH IN THIS LIMITED WARRANTY. IMPLIED WAR-
RANTIES ARE LIMITED TO THE STATED DURATION OF THIS LIMITED WARRANTY. Some states do not allow limitation on how long an implied warranty lasts, so that
limitation may not apply to you. In addition, some states do not allow the exclusion or limitation of incidental or consequential damages, so that above limitation or exclu-
sion may not apply to you. This warranty gives you specific legal rights and you may also have other rights which may vary from State to State. Send all inquiries regard-
ing warranty work to Tjernlund Products, Inc. 1601 9th Street, White Bear Lake, MN 55110-6794. Phone (651) 426-2993 • (800) 255-4208 • Fax (651) 426-9547 • Email:
[email protected]
REPLACEMENT PARTS LIST
ITEM PART NUMBER ITEM PART NUMBER
Gas Pressure Switch 950-2080 Motor Kit 950-3020
24V Transformer 950-2030 Linear Limit Spill Switch 950-2064
Wheel Kit 950-3010 Thermocouple Junction Adapter 950-0470
Relay Kit 950-1040 Housing Kit 950-3000