Carlin 301GAS Inst Manual User Manual

Carlin Equipment

Contents

PLEASE read this first.......................................................... 2
Codes and standards........................................................... 2
301GAS burner at-a-glance ................................................ 3
Prepare site • prepare burner • mount burner .............. 4
Install gas piping ................................................................ 10
Wire burner ......................................................................... 11
Check system • start-up burner/appliance .................. 12
Perform checkout procedures • fill out certificate..... 14
Maintenance and service procedures ........................... 16
Troubleshooting ................................................................. 17
Dimensions and mounting information........................... 19
Replacement parts............................................................. 20

Instruction manual

Ratings

Input

..............................................401,000 to 1,100,000 Btuh

Fuels

.........................................Natural gas or propane gas

Max. supply pressure ..........................14 inches w.c.

Min. supply pressure .............................5 inches w.c.

Manifold pressure...............................3.5 inches w.c.

Electrical

: Power ...........................................120V/60 Hz/1-Phase

Motor..............................1/6 HP, 3450 RPM, 1.8 amps

Total Current ................................... Approx. 2.5 amps

Ignition

........................Carlin Model 41800 solid state ignitor

Control

........ Carlin Model 60200FR microprocessor control

Agencies

: ..........................................................................UL Listed

Installer/servicer — Except where specifically
stated otherwise, this manual must be used only by a

quali-

fied service technician. (In the state of Massachusetts, this
product must be installed by a licensed Plumber or Gas Fitter.)
Failure to comply with this or other requirements in this manual
could result in severe personal injury, death or substantial
property damage.

User — Refer only to User’s Information booklet for
information regarding operation of this burner. The burner
Instruction Manual is intended only for your service techni-
cian. The burner and heat exchanger must be inspected and
started at least annually by your service technician.

™

70 Maple Street

East Longmeadow, MA 01028

Ph 413-525-7700

Fx 413-525-8306

Carlin Combustion Technology, Inc.

ech

support

800-989-2275

carlincombustion.com