Lincoln Electric IM980 RED-D-ARC EX350ie (CE) - Manual (Page 11)

A-2 INSTALLATION A-2
SELECT SUITABLE LOCATION
The EX350ie (CE) will operate in harsh environments.
Even so, it is important that simple preventative mea-
sures are followed in order to assure long life and reli-
able operation.
• The machine must be located where there is free cir-
culation of clean air such that air movement in the
back, out the sides and bottom will not be restricted.
• Dirt and dust that can be drawn into the machine
should be kept to a minimum. Failure to observe
these precautions can result in excessive operating
temperatures and nuisance shutdown.
• Keep machine dry. Shelter from rain and snow. Do
not place on wet ground or in puddles.
• DO NOT MOUNT OVER COMBUSTIBLE SURFACES.
Where there is a combustible surface directly
under stationary or fixed electrical equipment,
that surface shall be covered with a steel plate at
least .06”(1.6mm) thick, which shall extend not
less than 5.90”(150mm) beyond the equipment on
all sides.
------------------------------------------------------------------------
STACKING
EX350ie (CE) cannot be stacked.
TILTING
Place the machine directly on a secure, level surface
or on a recommended undercarriage. The machine
may topple over if this procedure is not followed.
INPUT AND GROUNDING CONNECTIONS
• Only a qualified electrician should connect the
EX350ie (CE). Installation should be made in accor-
dance with the appropriate National Electrical Code,
all local codes and the information detailed below.
• When received directly from the factory, multiple
voltage machines are internally connected for
440VAC. If 440VAC is the desired input, then the
machine may be connected to the power system
without any setup required inside the machine.
SAFETY PRECAUTIONS
ELECTRIC SHOCK can kill.
• TURN THE INPUT POWER OFF AT
THE DISCONNECT SWITCH BEFORE
ATTEMPTING TO CONNECT OR DIS-
CONNECT INPUT POWER LINES, OUTPUT
CABLES, OR CONTROL CABLES.
• Only qualified personnel should perform this
installation.
• Connect the green/yellow lead of the power
cord to ground per appropriate National
Electrical Code.
----------------------------------------------------------------------
WARNING
• Initial 200VAC - 415VAC operation will require an
Input voltage panel setup.
• Open the access panel on the rear of the machine.
• For 200 or 230: Position the large switch to 200-230.
For higher voltages: Position the large switch to ≥ 380.
• Move the "A" lead to the appropriate terminal.
POWER CORD CONNECTION
A 5 meter power cord is wired into the machine.
Follow the power cord connection instructions.
• Incorrect connection may result in equipment
damage.
------------------------------------------------------------------------
Single Phase Input
Connect green/yellow lead to ground per National
Electrical Code.
Connect blue and brown leads to power.
Wrap black lead with tape to provide 600V insulation.
Three Phase Input
Connect green/yellow lead to ground per appropriate
National Electric Code.
Connect blue, black and brown leads to power.
CONNECTIONS OF WIRE FEEDERS TO EX350ie
LN-10 Connection Instructions
• Turn the Invertec power switch "off".
• Connect the K1505 control cable from the LN-10 to
the 14-pin MS-style connector.
• Connect the electrode cable to the output terminal
of polarity required by the electrode. Connect the
work lead to the other terminal.
• Set the meter polarity switch on the front of the
Invertec to coincide with wire feeder polarity used.
• See the LN-10 manual for details on accessing
Control DIP Switch
W AR NIN G RE M OT E
PO W ER
OF F
ON
A A MPS
A
V V OLTS
W EL D T ER MIN AL S SE LE CT
OUTP UT LIN CO LN ELE CT RIC INV ER TE C V 35 0-P RO
W AR NIN G WA RN ING AV ISO DE PR EC AU CIO N
AT TE NT IO N
!
!
!
!
Lo rem ips um do lor sit am et c ons ecte tue r a dipi scing Lore m ip sum dol or s it a me t co nsec tetu er a dip iscin g elit, ed d iam no nu mmy nibh eu ism od tin cidu nt ut elit , e d di am non um my nibh eu ism od tin cidu nt u t laor eet d olo re ma gna al iqu am erat lao ree t do lore ma gna aliqu am era t Lor em ips um dol or s it ame t c ons ec tetu er ad ipis cing Lore m ip sum dol or s it a met con sec tetu er a dip iscin g elit, ed d iam n onu mmy nib h eui smo d tinc idun t u t elit , ed di am no nu mm y n ibh eu ismo d tin cidu nt u t lao ree t do lore m agn a a liquam er at lao ree t dol ore m ag na a liqu am e rat Lor em ips um d olo r s it ame t con sec tetu er a dipi scin g Lore m ip sum dolo r sit ame t co nse cte tue r a dip iscin g el it, ed dia m no nu mm y ni bh eu ismod tinc idu nt u t elit, ed dia m n onu mm y n ibh eu ism od t incidu nt u t laor eet d olo re ma gn a al iqua m e rat lao ree t dol ore ma gna aliq uam era t Lorem ips um do lor s it am et c ons ectetue r a dip iscing Lore m ip sum dol or s it a me t co nse ctet uer a dip iscin g elit, ed dia m n onumm y ni bh e uismo d ti nc idu nt u t elit , e d d iam n onu mm y n ibh eu ismo d tinc idun t ut laor eet dolo re m ag na a liqua m er at lao ree t do lore m ag na a liqua m era t Lor em ips um do lor s it am et c ons ecte tuer adi pisc ing Lore m ip sum do lor s it a met con sec tetu er a dip iscin g elit, ed dia m n on umm y n ibh e uismo d ti nc idu nt ut elit, ed dia m n onu mm y n ibh eu ism od ti ncid un t u t laor ee t d olor e ma gna aliq uam era t lao ree t dol ore m agn a a liqu am era t Lor em ips um d olo r s it a me t c ons ecte tue r a dip iscin g Lore m ip sum d olo r sit am et c ons ecte tue r ad ipis cing elit, ed di am non um my nib h e uismo d tinc idun t ut elit, ed d iam no num my nib h e uismo d ti ncid unt ut lao ree t do lore m agn a a liqu am era t lao ree t do lore m agn a a liqu am erat Lore m ips um dol or s it am et c on sec tetu er a dipi scing Lore m ip sum do lor s it am et c ons ectet uer adip iscin g elit, e d di am no nu mmy ni bh e uism od ti nc idu nt u t elit , ed dia m no num my nib h eu ism od tin cidu nt u t laor eet d olor e m ag na aliq uam e rat lao ree t dol ore m agn a a liqu am era t Lor em ips um d olo r sit am et c ons ecte tuer adi pisc ing Lore m ip sum d olo r s it a met co ns ecte tue r a dip iscin g elit, e d di am no nu mm y n ibh euis mod tinc idu nt ut elit , ed dia m n onu mm y n ibh eu ism od t incidu nt ut laor ee t d olo re m ag na a liqu am e rat lao ree t do lore m agn a al iqu am erat Lo rem ips um d olo r s it a met co ns ec tet ue r a dip iscin g Lore m ip sum d olo r sit ame t co nsec tetu er a dip iscin g elit, e d di am no numm y ni bh eu ism od tinc idunt ut elit, ed di am no numm y n ibh eu ism od t incid un t ut lao ree t do lor e m agna aliq uam erat lao ree t do lor e m agn a a liqu am era t
Lore m i ps um do lor sit am et c ons ec tetu er a dip iscin g Lore m ip sum dolor sit am et c ons ecte tuer ad ipis cing elit, ed d iam no nu mm y n ibh eu ism od t inc idu nt u t elit , ed dia m n onu mm y n ibh eu ism od tinc idu nt u t lao ree t d olo re m agn a a liqua m e rat lao ree t do lore m agn a a liqu am era t Lor em ips um d olor sit am et c ons ec tetue r ad ipis cing Lore m ip sum dol or s it a me t co nsec tetu er a dip iscin g elit, ed diam no nu mmy nibh euis mo d t incid unt ut elit , ed dia m n onu mmy nib h e uismo d tin cidu nt u t laor eet dolo re m agna al iqu am er at lao ree t do lore m agna aliq uam era t Lor em ips um do lor s it a met c on sec tetue r ad ipis cing Lore m ip sum dolo r sit am et c ons ecte tue r a dip iscin g elit, ed diam nonu mmy nibh eu ism od t inc idu nt u t elit , ed diam non um my nib h eu ism od t inc idu nt u t laor eet d olo re m ag na a liqu am erat lao ree t dol ore mag na a liqu am e rat Lor em ips um do lor sit am et cons ec tetue r ad ipis cing Lore m ip sum do lor sit a me t co nse cte tue r ad ipis cing el it, e d di am n onum my n ibh eui smo d t incid unt u t elit , ed dia m n onu mm y n ibh eui smo d tinc idu nt u t lao ree t d olo re m ag na aliq ua m e rat lao ree t do lore m agn a a liqu am e rat Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing
Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing elit, ed dia m non um my nib h e uism od t incid unt ut
elit , ed dia m non um my nib h e uism od t incid unt ut
lao ree t do lore m agn a a liqu am era t lao ree t do lore m agn a a liqu am era t Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing
Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing
elit, ed dia m non um my nib h e uism od t incid unt ut
elit, ed dia m non um my nib h e uism od t incid unt ut lao ree t do lore m agn a a liqu am era t lao ree t do lore m agn a a liqu am era t Lore m ipsu m d olo r sit am et c ons ecte tue r ad ipis cing
Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing
elit, ed dia m non um my nib h e uism od t incid unt ut
elit, ed dia m n onu mmy nib h e uism od t incid unt ut
lao ree t do lore m agn a a liqu am era t lao ree t do lore m agn a a liqu am era t Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing
Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing
elit, ed dia m n onu mm y n ibh eu ism od t incid unt ut
elit , ed dia m n onu mm y n ibh eu ism od t incid unt ut
lao ree t do lore m agn a a liqu am era t lao ree t do lore m agn a a liqu am era t
Lor em ips um dol or s it a me t co ns ec tetu er a dip iscing Lore m ip sum do lor s it a me t c ons ecte tue r a dipi scin g elit, e d di am no nu mm y ni bh e uism od tinc idu nt u t elit, ed diam no num my nib h e uism od t incid unt u t lao reet dol ore m agn a a liqua m era t lao ree t do lore m agn a a liqu am era t Lor em ips um do lor s it am et c ons ecte tue r ad ipis cing Lore m ip sum do lor s it am et c ons ecte tue r adi pisc ing el it, e d di am non umm y n ibh e uismo d t inc idun t u t elit, ed dia m no num my n ibh eu ismo d tinc idu nt u t lao ree t dol ore ma gna al iqu am e rat lao ree t dol ore ma gn a a liqu am er at
GREEN/YELLOW
BLUE
BLACK
BROWN
EX350ie (CE) (RED-D-ARC)
CAUTION
CAUTION