Analytical Industries GPR-1500 A Series Trace PPM Oxygen Analyzer - Manual (Page 40)

Advanced Instruments, Inc
40
Flammable Limits Not flammable
Extinguishing Method Not applicable
Special Fire Fighting
Procedures Not applicable
Unusual Fire and Explosion
Hazards Not applicable
Reactivity Data
Stability Stable
Conditions Contributing to
Instability None
Incompatibility KOH = Avoid contact with strong acids or Acetic Acid = Avoid contact with strong bases
Hazardous Decomposition
Products KOH = None or Acetic Acid = Emits toxic fumes when heated
Conditions to Avoid KOH = None or Acetic Acid = Heat
Spill or Leak
Steps if material is released Sensor is packaged in a sealed plastic bag, check the sensor inside for electrolyte
leakage. If the sensor leaks inside the plastic bag or inside an analyzer sensor housing
do not remove it without rubber or latex gloves and safety glasses and a source of
water. Flush or wipe all surfaces repeatedly with water or wet paper towel (fresh each
time).
Disposal In accordance with federal, state and local regulations.
Health Hazard Information
Primary Route(s) of Entry Ingestion, eye and skin contact
Exposure Limits Potassium Hydroxide - ACGIH TLV 2 mg/cubic meter or Acetic Acid - ACGIH TLV /
OSHA PEL 10 % (TWA), Lead - OSHA PEL .05 mg/cubic meter
Ingestion Electrolyte could be harmful or fatal if swallowed. KOH = Oral LD50 (RAT) = 2433 mg/kg
or Acetic Acid = Oral LD50 (RAT) = 6620 mg/kg
Eye Electrolyte is corrosive and eye contact could result in permanent loss of vision.
Skin Electrolyte is corrosive and skin contact could result in a chemical burn.
Inhalation Liquid inhalation is unlikely.
Symptoms Eye contact - burning sensation. Skin contact - soapy slick feeling.
Medical Conditions Aggravated None
Carcinogenic Reference Data KOH and Acetic Acid = NTP Annual Report on Carcinogens - not listed; LARC
Monographs - not listed; OSHA - not listed
Other Lead is listed as a chemical known to the State of California to cause birth defects or
other reproductive harm.
Special Protection
Information
Ventilation Requirements None
Eye Safety glasses
Hand Rubber or latex gloves
Respirator Type Not applicable
Other Special Protection None