Roberts Gorden EP 200 Series - Manual (Page 3)

© 2004
All rights reserved. No part of this work covered by the copyrights herein may be reproduced
or copied in any form or by any means - graphic, electronic, or mechanical, including
photocopying, recording, taping or information storage and retrieval systems - without the
written permission of Roberts-Gordon.
TABLE OF CONTENTS
SECTION 1: Heating System Safety ............................1
1.1 Manpower Requirements ...................................1
SECTION 2: Installer Responsibility............................2
2.1 Corrosive Chemicals...........................................2
2.2 National Standards and Applicable Codes .........2
SECTION 3: Unpacking the Pump ...............................2
3.1 Open Shipping Cartons ......................................2
SECTION 4: Major Components ..................................3
4.1 Standard Parts List .............................................4
SECTION 5: Pump Installation .....................................6
5.1 Pump Assembly Instructions ..............................6
5.2 Pump Suspension ..............................................9
5.3 Condensate Trap and Condensate Tee ............11
SECTION 6: Motor Wiring...........................................12
6.1 Prior to Operation .............................................12
SECTION 7: Venting ....................................................13
7.1 General Venting Requirements.........................13
7.2 Venting the Pump .............................................13
7.3 Horizontal Venting ............................................13
7.4 Vertical Venting.................................................15
SECTION 8: Servicing Instructions ...........................16
8.1 Pre-Season Maintenance and
Annual Inspection .............................................16
8.2 To Change the Motor and/or the Impeller .........16
8.3 Maintenance Checklist .....................................17
SECTION 9: Replacement Parts and Accessories ...18
9.1 Replacement Parts ...........................................18
9.2 Accessories ......................................................18
SECTION 10: Specifications.......................................19
SECTION 11: The ROBERTS GORDON
® EP-200
SERIES PUMP Limited Warranty .......21
Printed in U.S.A.