Pride Mobility SC3450 - Manual (Page 34)

34 Revo
Any electromechanical device requires occasional troubleshooting. However, most problems that arise can usually
be solved with a bit of thought and common sense. Many of these problems occur because the batteries are not
fully charged or because the batteries are worn down and can no longer hold a charge.
What if all the systems on my Revo seem to be “dead”?
n Make certain that the key is fully inserted into the key switch.
n Check that the batteries are fully charged. See VI. “Batteries and Charging.”
n Push in the main circuit breaker’s reset button. See V. “Your Revo.”
n Make certain that the wiring harness is firmly connected to the back of the battery/charger pack.
n Be sure the power down timer feature hasn’t been activated. See below.
POWER DOWN TIMER FEATURE
The scooter is equipped with an energy saving power down timer feature.
n If the scooter key switch is left in the on position and the scooter remains inactive for approximately 20
minutes, the motor controller will automatically shut down. This feature is designed to preserve battery life.
NOTE: Although the motor controller will be shut down by the power down timer feature, all activated
lights will remain on. For maximum battery life it is recommended that you turn off your lights or turn the
key to the off position.
To restore power back to the scooter:
n Remove the key from the key switch.
n Insert the key back into the key switch.
Your scooter will now resume normal operation.
What if the motor runs but my Revo does not move?
n Your Revo was probably left in manual freewheel mode.
n When the manual freewheel lever is pulled up, the brakes are disengaged and all power to the motor/transaxle
is cut.
n Push the manual freewheel lever down to restore normal operation to your Revo.
What if the main circuit breaker trips repeatedly? See V. “Your Revo.”
n Charge the Revo’s batteries more frequently. See VI. “Batteries and Charging.”
n If the problem persists, have both of your Revo’s batteries load tested by your authorized Pride provider.
n See VI. “Batteries and Charging” or IV. “Specifications” for information about your Revo’s battery type.
What if the battery condition meter dips way down and the motor surges or hesitates when I press my
Revo’s throttle control lever? See V. “Your Revo.”
n Fully charge your Revo’s batteries. See VI. “Batteries and Charging.”
n Have your authorized Pride provider load test each battery.
If you experience any problems with your Revo that you are not able to solve, contact your authorized Pride
provider for information, maintenance, and service.
X I . B A S I C T R O U B L E S H O O T I N G