Whelen IW37UF6P - Manual (Page 3)

Page 3
6
2
13 14
1
1
8 1 4 - 0 8 2 2 8 C - 0 6 D SCREW, 8-32 X 3/8" PAN TORX HD ROLOK SS BLK OXIDE
1 3 9 - 1 M 1 8 5 3 4 - 0 5 HSNG, PLUG 5 POS 18 AWG SL-156 W/ LOCKING RAMP, LID
1 4 6 - 0 7 4 6 9 0 9 - 0 0 ASS'Y, CABLE 4/C 16/20 GA TPR 20' SL-156
1 2 6 - 0 2 1 5 0 0 1 - 0 6 TY WRAP, 6" BLACK
1 0 1 - 0 2 6 E 7 6 3 - 0 0 SUB ASSY, WC I/O INNER-EDGE DUO XLP
1 4 6 - 0 7 6 E 7 6 4 - 0 0 ASSY, HARNESS PASSENGER J8 INNER EDGE XLP
1 4 6 - 0 7 6 E 7 6 4 - 0 1 ASSY, HARNESS PASSENGER J7 INNER EDGE XLP
0 1 - 0 2 6 E 7 5 6 D * 3 SUB ASSY, WARNING */WHT DUO INNER-EDGE XLP, DRVR
0 1 - 0 2 6 E 7 5 6 P * 3 SUB ASSY, WARNING */WHT DUO INNER-EDGE XLP, PASS
4
1
1
1
1
1
1
0 1 - 0 6 8 7 4 7 2 - _ 1 DUO INNER EDGE XLP, WC 6 LT
2 3 8 - 0 5 4 6 8 2 7 - 1 4 TRIM, SEAL HSNG/WINDSHIELD 13.600" LENGTH INNER EDGE XLP 1
1 1 0 - 0 5 6 E 5 6 3 - 3 0 1 LABEL, WHELEN LOGO, 2.75" GREY
0 1 - 0 6 8 7 4 7 2 - _ 2 DUO INNER EDGE XLP, WC 12 LT
LABEL, INNER EDGE XLP, M/N P/N DUO 1 0 - 0 5 6 E 8 3 1 - * * 1 1
SCREW, 4-40 X 1/4 PPHMS 410SS BLACK PASSIVATE 1 4 - 0 4 0 2 1 6 - 0 4 H 26 14
ASSY, HARNESS DRIVER J5&J6 INNER EDGE XLP 4 6 - 0 7 6 E 7 6 4 - 0 2 1
6 6
6
1 0 - 0 5 4 6 9 3 5 - 1 8
7 9 - 0 0 0 A 0 0 5 - 0 0
0 1 - 0 4 6 E 8 6 8 - 0 0 1 1
1 1
1 1
DEFAULT, DUO INNER EDGE XLP WECAN
LABEL, UCP, DFLT, DUO INNER EDGE XLP
KIT, UNIVERSAL CONTROL POINT MODULE
2
3
ITEM PART NUMBER DESCRIPTION QTY QTY
11
12
13
14
15
16
17
4
5
6
7
8
9
10
1
10
0 1 - 0 6 8 7 4 7 2 - 9 1
0 1 - 0 6 8 7 4 7 2 - 9 2
11 - 2 6 E 7 4 0 - 1 0 7
11 - 2 6 E 7 4 0 - 0 0 7
0 7 - 2 8 7 4 1 9 - 1 2 3
0 7 - 2 8 7 4 1 9 - 0 2 3
11 - 3 6 E 4 9 4 - 0 0 7
11 - 3 6 E 4 9 4 - 1 0 7
1
1
1 1
1
1
1
1 1
BASE, HOUSING DRVR 12 CAPRICE INNER EDGE XLP BLACK
COVER, TOP DRVR 12 CAPRICE DUO INNER EDGE XLP BLACK
COVER, TOP PASS 12 CAPRICE DUO INNER EDGE XLP BLACK
BASE, HOUSING PASS 12 CAPRICE INNER EDGE XLP BLACK
BRACKET, VISOR MT DRVR CAPRICE INNER EDGE XLP BLACK
BRACKET, VISOR MT PASS CAPRICE INNER EDGE XLP BLACK
1 4 - 0 8 2 2 8 C - 0 6 D
1 5 - 1 0 1 4 1 B - 1 6 2
2 4
1 2
SCREW, 8-32 X 3/8" PAN TORX HD ROLOK SS BLACK OXIDE
SCREW, 10 X 1" PPH SMS TYPE A SS BLACK OXIDE
FINAL, DUO INNER EDGE XLP, 6 LIGHT
FINAL, DUO INNER EDGE XLP, 12 LIGHT
B
C
ITEM PART NUMBER DESCRIPTION QTY QTY
D
E
F
G
H
A
2013 - CHEVY
CAPRICE PPV
PART NUMBER KEY
0 1 - 0 6 8 7 4 7 2 - 9 _
VERSION
6 LT
12 LT 1 =
2 =
Your lightbar should now be fully operational. If it is not functioning
properly, check your connections for the following:
• The positive wire (RED) is properly connected to the battery, by way of
the user supplied fuse block.
• A working fuse of the correct amperage is installed in the fuse block
(See illustration above, for the specific fuse rating for your lightbar).
• The ground wire (BLACK) is properly connected to the factory ground.
Be sure that the wire is fully grounded to this location.
• The two communication wires (GREEN and GREY) are properly
connected to their communication designations.
If these connections are good, contact your Whelen® representative for further
assistance.
IMPORTANT! Before returning this vehicle to active service, visually
confirm the proper operation of this product, as well as all vehicle
components/equipment.