Kleenmaid FE904C User Manual
Page 43
CLEANING AND MAINTENANCE
5.4
Cleaning the BBQ Grill (FED Model)
The BBQ grill plates, element, volcanic rocks and smokeless grill tray are removable for cleaning. The grill plates
and tray are dishwasher safe and the fixed grill box (in the unit) can be easily wiped clean.
WARNING: Built up cooking fats in the unit may ignite during use. To avoid the build up of cooking fats the BBQ unit
must be regularly cleaned. Volcanic rocks are absorbent and may entrap cooking fats within the rock pores.
When cleaning the unit, the rocks should be removed and cleaned by soaking in warm soapy water and
then thoroughly rinsed with hot water. The best way to avoid fat build up in addition to cleaning is to
periodically replace the BBQ rocks. With normal usage it is recommended that the rocks be replaced every
six months. The rocks may need to be replaced at different intervals depending on the unit’s usage.
5.5
Removing Oven Door (downward opening door models only)
The oven door can be easily removed for better access while cleaning. To remove the oven door:–
1. Open the door fully and pull the clips toward you onto the hooks.
2. Raise the door slightly and, holding the sides of the door about half way up and making sure the clips stay on
the hooks, lift the door gently. This should disconnect the hinges from the oven frame.
3. Remove the door by continuing to raise it while pulling the door away from the oven. When handling the door
be careful not to dislodge the clips off the hooks. If so the hinge will have to be closed by hand and the clip re
engaged onto the hook before re-fitting onto the oven.
To re-fit the oven door:-
1. Holding the door at an angle to the oven, slide the hinges into the oven frame, making sure that on each side
the top, curved arm fits into the top slot and the lower arm fits into the bottom slot.
2. Make sure the hinges are pushed in as far as they will go and the lower arm engages into the plate mounted in
the oven frame.
3. Open the door completely and disengage the clips from the hooks. You may need to push the clips down with
your finger if they do not fall away from the hooks by themselves. The door can now be opened and closed as
normal.
41