Glow-worm Clearly Heat Recovery - Manual (Page 12)

12
4 Installation
4.1 Contents of Pack
• Atmosorb unit
• Digital remote control
• Mounting set consisting of:
• Fixing brackets 405 x 60 mm
• Condensate drain trap
Accessories (optional)
• Bypass Atmosorb
• Filtersets H.E. F6
Ensure that the wall offers the appropriate load carrying
capacity and that appropriate fixing are used to secure the
unit. It is possible that the attached mounting set with the
fixing screws and wall plug is not suitable for every wall.
The ventilation unit weighs about 35 kg. When hooking the
unit onto the fixing bracket, never lift the unit alone.
NOTE: This unit is solely intended for vertical wall mounting.
When mounting the system it is absolutely necessary to
ensure the horizontal positioning of the ventilation unit and an
angle of > 0° and < 1° in vertical position to ensure that the
condensation water can easily flow out of the unit.
4.2 Installation of the Unit
With due regards to the minimum clearances, condensate
drain position and ducting, mark and drill the position for the
wall bracket securing screws, see diagram 4.1.
Secure the wall bracket with suitable wall fixings.
Mount the unit, by hooking over the wall bracket, see diagram
4.1.
4.3 Connection of the Condensate Drain
Fit the connecting piece for the condensate drain trap to the
connection outlet on the bottom of the unit.
Connect the attached condensate drain trap with the
connection piece, see diagram 4.2.
IMPORTANT:
For the condensate discharge of the unit a
second drain trap is required, see diagram 4.3.
For hygienic reasons, the condensate drain trap must not be
directly connected to the waste water system.
An air gap of at least 20 mm must be provided. A wrongly
installed condensate outlet can lead to condensate
accumulation and to an uncontrollable escape of condensate.
Use of the customer service and possible subsequent
damages are not covered by the Glow-worm warranty.
Diagram 4.1
14883
Diagram 4.2
15530
0-1˚
300 min
clearance
945 min
WALL MOUNTING
BRACKET
CONNECTING
PIECE AND
WASHER
CONDENSATE
DRAIN TRAP
CONDENSATE
DRAIN OUTLET