Vermont Casting VCS4005 - Manual (Page 5)

B. SAFE USE OF LP (PROPANE) GAS
DANGER:
• Never install a propane cylinder that is more than 80 % full, as the contents may lack adequate
room for expansion when exposed to heat. Propane vapor may then be vented through the pres-
sure release valve, which could accumulate in a pool and later result in a fire or explosion.
Always instruct your certified propane fuel supplier to confirm by weight that your cylinder
is not more than 80 % full. An empty cylinder will weigh about 18 lb., while a properly filled
cylinder should weigh no more than 38 lb.
• Never store a spare Propane Cylinder in the cylinder compartment of this Grill. Exposing a
disconnected cylinder to heat could result in the venting of propane vapor through the pressure
release valve, and the pooled vapor could result in a violent fire. (No hazard is posed by the
connected cylinder if it is not overfilled, however, as it tends to refrigerate itself while it is being
used.)
Always confirm that all openings in the cylinder compartment of this Grill are free of any ob-
structions that would restrict the circulation of ventilation air. Good ventilation will prevent the
pooling of leaked propane vapor, which is heavier than air, and which could explode if ignited.
WARNINGS:
• Always consult the Rating Label on the back of the Grill to confirm which fuel must be
used with the Grill. Never operate the Grill with propane gas if it has been configured
to use natural gas, to prevent hazardous overheating.
• Always confirm that there are no gas leaks before lighting this Grill. Apply a 50/50
solution of liquid soap and water to the gas supply line connectors with a brush or spray
bottle, and watch for bubbles. Never use a match or open flame to test for gas leaks.
• Always visually inspect the gas supply line for fraying, cracking or rodent damage
before each use of this Grill and, if necessary, install a replacement obtained from your
dealer before lighting this Grill.
Always store your spare Propane Gas Cylinders in an outdoor area that is well-ventilated, shady,
cool and removed from any heat source. Always store those cylinders in an upright position.
Never store a spare cylinder in the vicinity of this Grill, or in the vicinity of any other heat-gener-
ating appliance.
C. SAFE USE OF NATURAL GAS
• Always consult the Rating Label on the back of the Grill to confirm which fuel must be used
with the Grill. Never attempt to operate the Grill with natural gas if it has been configured to
use propane gas, to prevent possible bodily injury.
• Always employ a qualified service agency to install all necessary gas supply plumbing, for
safety reasons and to assure compliance with all applicable Codes.
Page iv
Warnings