Char-Broil 4638220 - Manual (Page 12)

WARNING
• Do not use grill until leak checked.
• If leak is detected at any time, STOP and call the Fire
Department.
• If you cannot stop a gas leak, immediately close LP tank
Valve and call LP gas supplier or your fire department!
Leak Testing Valve and Hose
1.
2.
Check to make sure grill is connected to natural gas source
and gas supply is turned on.
3. Brush a soapy solution onto areas and connections shaded
In illustration below.
Turn all grill control knobs to OFF.
4. bubbles appear, there is a leak. Turn gas off at
control knobs and gas source immediately and retighten
connections.
Call for replacement parts. Order new parts by
giving the serial, model number and name of items needed
To the Grill Service Center at
.
“If growing”
If leaks cannot be stopped “do not try to
repair.”
1-800-241-7548
Safety Tips
s
s
s
s
s
s
s
When grill is not in use, turn off all control knobs and gas
source.
Never move grill while in operation or still hot.
Use long-handled barbecue utensils to avoid burns and
splatters.
Maximum load for side shelves is 10 lbs.
A soup can
be attached to grease clip and emptied
after each use. Do not remove soup can until grill has
completely cooled.
If you notice grease or other hot material dripping from grill
onto valve or hose, turn off gas supply at once. Determine
the cause, correct, clean and inspect valve and hose before
continuing. Perform a leak test.
If you have a grill problem see the
.
must
"Troubleshooting
Section"
WARNING
For Safe Use of Your Grill and to Avoid
Serious Injury:
•
•
•
•
•
•
• Use grill at least 3 ft. from any
wall or surface.
• Apartment Dwellers:
• NEVER attempt to light burner with lid closed. A
buildup of non-ignited gas inside a closed grill is
hazardous.
Do not let children operate or play near grill.
Keep grill area clear and free from materials that burn.
Do not block holes in bottom or back of grill.
Check burner flames regularly.
Use grill only in well-ventilated space. NEVER use in
enclosed space such as carport, garage, porch, covered
patio, or under a surface that can catch fire.
Do not use charcoal in a gas grill.
Maintain 10 ft.
clearance to objects that can catch
fire or sources of ignition such as
pilot lights on water heaters, live
electrical appliances, etc.
Check with management to learn the requirements and fire
codes for using an Gas Grill in an apartment. If allowed use
outside on the ground floor with a three (3) foot clearance
from walls or rails. Do not use on or under balconies made
of wood.
CAUTION
• Putting out grease fires by closing the lid is not
possible. Grills are well ventilated for safety reasons.
• Do not use water on a grease fire. Personal injury may
result. If a grease fire develops turn knobs and gas
source off.
• Do not leave grill unattended while preheating or
burning off food residue on high. If grill has not been
regularly cleaned a grease fire can occur that may
damage the product.
Before Your First Cookout
• Light burners, check to make sure they are lit, close the lid
and warm up grill on HIGH for 15 minutes. Curing of paint and
parts will produce an odor only on first lighting.
s Never remove opening
at end of valve.
12 • 4638220