Great Plains TA520S Operator Manual - Manual (Page 60)

1993-1995 Tandem Axle Sprayer
500-061M 3/18/2005
58
Storage
1. Empty solution from the tank, clean the chemical in-
ductor {if included}, and store or dispose of the
chemical as recommended by the manufacturer’s
chemical label.
2. Flush the entire sprayer system with clean water.
3. Clean out Whirlfilters ® . Refer to "Operating Whirl-
filter ® " on Page 24.
4. Circulate 3 - 5 gallons of antifreeze {Great Plains
strongly recommends the use of recreational vehicle
antifreeze} through the system including the pump,
hoses and nozzles. Drain the sprayer and properly
dispose of antifreeze. It is advisable to remove the
pump and store it in a warm, dry environment during
the winter. Keep antifreeze in the pump to prevent
gasket shrinkage.
Note: Regular antifreeze is harmful or fatal to animals
and humans. Use carefully according to the label’s in-
structions. We strongly recommend the use of recre-
ational vehicle antifreeze which does not exhibit these
harmful side effects.
5. Remove nozzles, disconnect the control box, and
place them indoors with the pump.
6. Change filters in the tractor cab after finished.
7. Wash off the exterior of the sprayer thoroughly using
a safe solvent or soap and water.
8. Inspect all parts of the sprayer for wear and rust. Re-
pair and paint parts as necessary.
9. Store the sprayer in a dry area away from direct sun-
light.
Maintenance & Lubrication Record
Item to be Serviced When to Perform Reference Date