Watts LF919 - Manual (Page 8)

RP/IS-919 1145 EDP# 1915346 © 2012 Watts
USA: Tel: (978) 688-1811 • Fax: (978) 794-1848 • www.watts.com
Canada: Tel: (905) 332-4090 • Fax: (905) 332-7068 • www.wattscanada.ca
Limited Warranty: Watts Regulator Co. (the “Company”) warrants each product to be free from defects in material and workmanship under normal usage for a period of one year from the date of
original shipment. In the event of such defects within the warranty period, the Company will, at its option, replace or recondition the product without charge.
THe WARRANTY SeT FORTH HeReiN iS GiVeN eXPReSSLY AND iS THe ONLY WARRANTY GiVeN BY THe COMPANY WiTH ReSPeCT TO THe PRODUCT. THe COMPANY MAKeS NO OTHeR
WARRANTieS, eXPReSS OR iMPLieD. THe COMPANY HeReBY SPeCiFiCALLY DiSCLAiMS ALL OTHeR WARRANTieS, eXPReSS OR iMPLieD, iNCLUDiNG BUT NOT LiMiTeD TO THe iMPLieD
WARRANTieS OF MeRCHANTABiLiTY AND FiTNeSS FOR A PARTiCULAR PURPOSe.
The remedy described in the first paragraph of this warranty shall constitute the sole and exclusive remedy for breach of warranty, and the Company shall not be responsible for any incidental, special
or consequential damages, including without limitation, lost profits or the cost of repairing or replacing other property which is damaged if this product does not work properly, other costs resulting
from labor charges, delays, vandalism, negligence, fouling caused by foreign material, damage from adverse water conditions, chemical, or any other circumstances over which the Company has no
control. This warranty shall be invalidated by any abuse, misuse, misapplication, improper installation or improper maintenance or alteration of the product.
Some States do not allow limitations on how long an implied warranty lasts, and some States do not allow the exclusion or limitation of incidental or consequential damages. Therefore the above
limitations may not apply to you. This Limited Warranty gives you specific legal rights, and you may have other rights that vary from State to State. You should consult applicable state laws to
determine your rights. SO FAR AS iS CONSiSTeNT WiTH APPLiCABLe STATe LAW, ANY iMPLieD WARRANTieS THAT MAY NOT Be DiSCLAiMeD, iNCLUDiNG THe iMPLieD WARRANTieS OF
MeRCHANTABiLiTY AND FiTNeSS FOR A PARTiCULAR PURPOSe, ARe LiMiTeD iN DURATiON TO ONe YeAR FROM THe DATe OF ORiGiNAL SHiPMeNT.
A Watts Water Technologies Company
For additional cross-connection control information, send for F-50 brochure.
Symptom Cause Solution
1. Check valve fails to hold a. Debris on check disc Disassemble and clean
1.0 PSID minimum sealing surface
b. Leaking gate valve Disassemble and clean or repair
c. Damaged seat disc or Disassemble and replace
seat o-ring
d. Damaged guide holding Disassemble clean or replace
check open
e. Weak or broken spring Disassemble and replace spring
2. Chatter during flow a. Worn, damaged or Disassemble and repair or
conditions defective guide replace guide
3. Low flows passing a. Mainline check fouled Disassemble and clean
through mainline
valve b. Meter strainer plugged Disassemble and clean
c. Damaged mainline seat Disassemble and replace
disc or seat
d. Broken mainline spring Disassemble and replace
Troubleshooting Guide
Series 919 and LF919