Banner SureCross DX81P6 FlexPower Supply Module - Manual

Datasheet
• Wireless solution for powering a FlexPower Node and sensor device
• Unique power management system to run the FlexPower Node and a device
through switched power outputs for up to 5 years, depending upon the power
requirements of the device
• Six 3.6 V dc lithium “D” cell batteries
• IP67 sealed enclosure
FlexPower systems allow for a true wireless solution as the Node can be powered by
battery power (3.6 to 5.5 V dc). Battery life is application specific. Contact Banner
Engineering’s application engineers for a battery life calculation for your specific
application.
For additional information, updated documentation, and accessories, refer to Banner
Engineering's website, www.bannerengineering.com/surecross .
Model Power Batteries Cable
DX81P6 3.6 V dc battery Six 3.6 V Lithium "D" Cells 5-pin Euro pigtail QD
Specifications
Estimated Battery Life
114,000 mA·hours
Housing
Polycarbonate housing and rotary dial cover; polyester
labels; EDPM rubber cover gasket; nitrile rubber, non-
sulphur cured button covers
Weight: 0.98 kg (2.15 lbs)
Mounting: 1/4-inch or M7 (SS M7 hardware included)
Max. Tightening Torque: 0.56 N·m (5 lbf·in)
Wiring Access
One 1/2-inch NPT with 5-pin Euro-style 150 mm
pigtail QD
Operating the devices at the maximum operating conditions
for extended periods can shorten the life of the device.
Environmental Rating
IEC IP67; NEMA 6; (See UL section below for any
applicable UL specifications)
Operating Conditions
Operating Temperature: −40 to 85 °C
Operating Humidity: 95% max. relative (non-
condensing)
Radiated Immunity: 10 V/m, 80-2700 MHz
(EN61000-6-2)
Shock and Vibration
IEC 68-2-6 and IEC 68-2-7
Shock: 30g, 11 millisecond half sine wave, 18 shocks
Vibration: 0.5 mm p-p, 10 to 60 Hz
5-pin Euro-Style Female Wiring for DX81
Use the battery supply module to power FlexPower ® devices only.
5-pin Euro-Style Female Connector Pin Wire Color Description DX80...C Terminals
1
2
3
4
5
3 Blue dc common (GND) V-
5 Gray 1 3.6 V dc B+
1 Do not apply more than 5.5 V dc to the gray wire.
SureCross DX81P6 FlexPower Supply
Module
P/N 131628 Rev. D 2 January 2014
0 131628 5