Section 1. specifications, 1 operating specifications, 2 capacities – JLG 600A_AJ Service Manual User Manual
Page 17: 3 component data, Engine data, Section 1 - specifications, Operating specifications -1, Capacities -1, Component data -1, Engine data -1
SECTION 1 - SPECIFICATIONS
3121201
– JLG Lift –
1-1
SECTION 1. SPECIFICATIONS
1.1 OPERATING SPECIFICATIONS
1.2 CAPACITIES
1.3 COMPONENT DATA
Engine Data
Table 1-1. Operating Specifications
Maximum Work Load (Capacity)
Unrestricted:
Restricted:
500 lb (230 kg)
1000 lb (450 kg)
Maximum Travel Grade (Gradeability)
2WD
4WD
30%
45%
Maximum Travel Grade (Side Slope)
5°
Turning Radius - (outside)
2WS
4WS
17 ft. 8 in. (5.38 m)
11 ft. 8 in. (3.56 m)
Turning Radius -
(outside) narrow chassis
2WS
4WS
16 ft. 6 in. (5.03 m)
11 ft. 2 in. (3.4 m)
Turning Radius - (inside)
2WS
4WS
11 ft. 5 in. (3.48 m)
5 ft. 6 in. (1.68 m)
Turning Radius - (inside) narrow chas-
sis
2WS
4WS
12 ft. 2 in. (3.71 m)
5 ft. 7 in. (1.7 m)
Maximum Tire Load:
11,500 lbs. (5227 kg)
Ground Bearing Pressure
600A
600AJ
600A - narrow chassis
600AJ - narrow chassis
77 psi (5.4 kg/cm
2
)
75 psi (5.3 kg/cm
2
)
94 psi (6.6 kg/cm
2
)
94 psi (6.6 kg/cm
2
)
Maximum Drive Speed - A Models
2WD
4WD
3.6 MPH (5.80 Km/hr.)
4 MPH (6.44 Km/hr.)
Gross Machine Weight (Approximate)
600A
600AJ
600A - narrow chassis
600AJ - narrow chassis
21,500 lbs. (9,752 kg)
22,200 lbs. (10,025 kg)
23,900 lbs. (10,841 kg)
24,000 lbs. (10,886 kg)
Table 1-2. Capacities
Fuel Tank
30 U.S. Gallons (113.6 L)
Hydraulic Oil Tank
30.6 Gallons (115.8 L) with 10%
air space
Hydraulic System (Including Tank)
36.72 Gallons (139 L)
Torque Hub, Drive
*
17 ounces (0.50 L)
Engine Crankcase
Ford LRG-425 Gas w/Filter
Deutz F4M2011F Diesel w/Filter
Caterpillar 3044C Diesel w/Filter
GM 3.0L w/Filter
4.5 quarts (4.25L)
11 quarts (10.5 L)
10.6 quarts (10 L)
4.5 qts. (4.25 L)
Cooling System
16 Quarts (15.14 L.)
*Torque hubs should be one half full of lubricant.
Table 1-3. Ford LRG-425 Specifications
Fuel
Gasoline
Crankcase Capacity
4.5 Quarts (4.25 L) w/Filter
Idle RPM
1000
Low RPM
1800
High RPM
2800
Alternator
40 Amp, Belt Drive
Battery
85 Amphour, 550 Cold Cranking
Amps, 12 VDC
Fuel Consumption
Low RPM
High RPM
3.45 GPH (13.06 lph)
4.60 GPH (17.41 lph)
Horsepower
54 @ 2400 RPM, full load
Cooling System
16 Quarts (15.14 L.)
Spark Plug
AWSF-52-C
Spark Plug Gap
0.044 in. (1.117 mm)