JLG 600SC_660SJC Service Manual - Manual (Page 19)

SECTION 1 - SPECIFICATIONS
3121157 – JLG Lift – 1-1
SECTION 1. SPECIFICATIONS
1.1 OPERATING SPECIFICATIONS
1.2 CAPACITIES
1.3 ENGINE DATA
Table 1-1. Operating Specifications
Maximum Work Load (Capacity)
Unrestricted:
Restricted - 600SC
Restricted - 660SJC
500 lb. (230 kg)
1000 lb. (450 kg)
500 lb. (230 kg)
Maximum Travel Grade (Gradeability)
* 55%
Maximum Travel Grade (Side Slope)
* 5°
Max.Vertical Platform Height:
600SC
660SJC
60 ft. 3 in. (18.36 m)
66 ft. 8 in. (20.32 m)
Max.Horizontal Platform Reach:
600SC
660SJC
49 ft. 6 in. (15.09 m)
56 ft. 9 in. (17.3 m)
Turning Radius - Inside 0
Turning Radius - Outside 8 ft. (2.4 m)
Maximum Ground Bearing Pressure
600SC
660SJC
5.45 psi (0.383 kg/cm 2 )
6.5 psi (0.457 kg/cm 2 )
Maximum Drive Speed: 1.6 mph (2.6 kph)
Max. Hydraulic System Pressure 4500 psi (310 Bar)
Maximum Wind Speed 28 mph (12.5 m/s)
Maximum Manual Force 101 lb. (450 N)
Electrical System Voltage 12 Volts
Gross Machine Weight (Platform Empty)
600SC
660SJC 22,500 lb. (10,205 kg)
27,100 lb. (12,292 kg)
*
With boom in stowed position.
Table 1-2. Capacities
Fuel Tank 39 US. Gallons (147.6 L)
Hydraulic Oil Tank 31 U.S. Gallons (117.3 L)
Hydraulic System (Including Tank) 37.2 U.S. Gallons (140.8 L)
Engine Crankcase
Deutz w/Filter
Caterpillar (w/filter)
11 quarts (10.5 L)
10.6 quarts (10 L)
Table 1-3. Deutz F4M1011F/F4M2011 Specifications
Fuel Diesel
Oil Capacity
Cooling System
Crankcase
Total Capacity
5 Quarts (4.5 L)
11 Quarts (10.5 L) w/Filter
16 Quarts (15 L)
Idle RPM 1000
Low RPM 1800
High RPM 2800
Alternator 60 Amp, belt drive
Battery 1000 Cold Cranking Amps, 210
Minutes Reserve Capacity, 12
VDC
Fuel Consumption
Low RPM
High RPM
1.90 GPH (7.19 lph)
2.50 GPH (9.46 lph)
Horsepower 65 @ 3000 RPM, full load
Table 1-4. Deutz D2011L04 Specifications
Fuel Diesel
Oil Capacity
Cooling System
Crankcase
Total Capacity
5 Quarts (4.5 L)
11 Quarts (10.5 L) w/Filter
16 Quarts (15 L)
Idle RPM 1000
Low RPM 1800
High RPM 2600
Alternator 60 Amp, belt drive
Battery 1000 Cold Cranking Amps, 210
Minutes Reserve Capacity, 12
VDC
Fuel Consumption
Low RPM
High RPM
1.90 GPH (7.19 lph)
2.50 GPH (9.46 lph)
Horsepower 64 @ 2600 RPM, full load