Rugged Ridge Front Tube Doors, Textured Black, 07-14 Jeep Wrangler (JK) - Manual

Page 1 of 3
Contents:
Tube Door (latches installed) (2)
Mirror Stanchion (2)
Adjustable Nylon Strap (2)
Anti-Rattle Bumper (2)
Self Tapping Screw (2)
JK FRONT TUBE DOORS
11509.10 Front Tube Doors
This product is intended to provide added “off-road” convenience and utility to your vehicle.
This product is not intended to provide occupant containment or protection in the event of an accident or roll-
over. Further, “on road” use may involve increased risk of serious injury in the event of side-impact accidents. To
reduce risk from these types of injuries: Always wear seat belt and shoulder harness for all vehicle occupants.
Keep arms and body inside vehicle. Drive safely, read and understand all manufacturers warnings and product
instructions before installation.
3. Remove the torx nut from the bottom of each factory hinge pin.
Set these nuts aside to be re-installed on the Tube Doors. To remove the
factory doors, carefully lift the door upward until the hinge pins completely
clear the hinges. It will be helpful to have someone else assist with this step.
2. Locate the driver side door strap that limits the door opening. At the
end of the strap, disconnect the electrical connector by releasing the red
locking tab and pulling down on the connector. Next, remove the strap
from the hook located inside the vehicle. Repeat for passenger door.
NOTICE ! The door can swing open into the vehicle once the strap is released
potentially causing damage to your vehicle.
1. Locate the (2) torx head bolts that secure the driver side mirror to the
vehicle. With the driver window open, hold on to the mirror with one hand
while loosening the torx bolts with the other hand. Be sure not to let the
mirror drop after removing these bolts. Repeat for passenger side. Set
mirrors aside to be re-installed on the Tube Doors. NOTE: If you have a 2011
and up model Wrangler and your vehicle is equipped with power mirrors,
disconnect wiring at the mirror after removal.