A.J. Antunes & Co CCC-20 9600218 - Manual (Page 9)

9
CORN COOKER
P/N 1010634 Rev. I 03/06
TROUBLESHOOTING
WARNING
To avoid possible personal injury and/or damage to the unit, inspection, test and repair of electrical equip-
ment should be performed by qualified service personnel. The unit should be unplugged when servicing,
except when electrical tests are required. Use extreme care during electrical circuit tests. Live circuits will
be exposed.
Problem Possible Cause Corrective Action
Rocker Switch (power On/Off) is ON,
but the unit does not heat and the
light on the Rocker Switch is OFF.
The power cord is not correctly
plugged in.
Plug power Cord into appropriate
outlet.
Circuit Breaker tripped. Reset the Circuit Breaker.
Damaged Power Cord. Replace Power Cord.
Loose, burnt, or broken wires in
circuit.
Tighten wires and replace if burned
or charred.
Inoperable Rocker Switch. Replace Rocker Switch.
Safety Interlock Switch not engaged. Reposition the Head Assembly to
engage the Safety Interlock Switch
according to the operating instruc-
tions in this manual..
Unit overheats or overcooks (water
boils).
Inoperable Thermostat. Replace the Thermostat
Water level is too low. Add water so that the corn is com-
pletely covered.
Unit under cooks the corn. Inoperable Thermostat. Replace the Thermostat.
Rocker Switch (power On/Off) is ON,
the unit does not heat, but the light
on the Rocker Switch is ON.
Inoperable Heating Element Replace the Heating Element.
Inoperable Thermostat. Replace the Thermostat.
Loose, burnt, or broken wires in
circuit.
Replace wires.