Lincoln Electric IM764 RED-D-ARC EX350i - Manual (Page 9)

A-2 INSTALLATION A-2
SELECT SUITABLE LOCATION
The EX350i will operate in harsh environments. Even
so, it is important that simple preventative measures
are followed in order to assure long life and reliable
operation.
• The machine must be located where there is free cir-
culation of clean air such that air movement in the
back, out the sides and bottom will not be restricted.
• Dirt and dust that can be drawn into the machine
should be kept to a minimum. Failure to observe
these precautions can result in excessive operating
temperatures and nuisance shutdown.
• Keep machine dry. Shelter from rain and snow. Do
not place on wet ground or in puddles.
• DO NOT MOUNT OVER COMBUSTIBLE SURFACES.
Where there is a combustible surface directly
under stationary or fixed electrical equipment,
that surface shall be covered with a steel plate at
least .06”(1.6mm) thick, which shall extend not
less than 5.90”(150mm) beyond the equipment on
all sides.
------------------------------------------------------------------------
STACKING
EX350i cannot be stacked.
TILTING
Place the machine directly on a secure, level surface
or on a recommended undercarriage. The machine
may topple over if this procedure is not followed.
INPUT AND GROUNDING CONNECTIONS
• Only a qualified electrician should connect the
EX350i. Installation should be made in accordance
with the appropriate National Electrical Code, all
local codes and the information detailed below.
• When received directly from the factory, multiple
voltage machines are internally connected for
460VAC. If 460VAC is the desired input, then the
machine may be connected to the power system
without any setup required inside the machine.
• Initial 200VAC - 415VAC and 575VAC operation will
require an Input voltage panel setup.
SAFETY PRECAUTIONS
ELECTRIC SHOCK can kill.
• TURN THE INPUT POWER OFF AT
THE DISCONNECT SWITCH BEFORE
ATTEMPTING TO CONNECT OR DIS-
CONNECT INPUT POWER LINES, OUTPUT
CABLES, OR CONTROL CABLES.
• Only qualified personnel should perform this
installation.
• Connect the green/yellow lead of the power
cord to ground per National Electrical Code.
----------------------------------------------------------------------
WARNING
• Open the access panel on the rear of the machine.
• For 200 or 230: Position the large switch to 200-
230.
For higher voltages: Position the large switch to
380-575.
• Move the "A" lead to the appropriate terminal.
POWER CORD CONNECTION
A 25 ft. power cord is provided and wired into the
machine. Follow the power cord connection instruc-
tions.
• Incorrect connection may result in equipment
damage.
-----------------------------------------------------------------------
Single Phase Input
Connect green lead to ground per National Electrical
Code.
Connect black and white or brown leads to power.
Wrap red lead with tape to provide 600V insulation.
Three Phase Input
Connect green lead to ground per National Electric
Code.
Connect black, red and white leads to power.
CONNECTIONS OF WIRE FEEDERS TO EX350I
LN-25 Connection Instructions
-Not recommended for Pulse Welding with the
Advanced Process Kit ).
• Turn the EX350i power switch "off".
• Connect the electrode cable to the output terminal of
polarity required by electrode. Connect the work lead
to the other terminal.
• LN-25 with Remote Control options can be used with
the EX350i. The 14 pin (K444-2) remote can be con-
nected directly to the 14 pin amphenol. The 42 Volt
Remote Voltage and Output Control (K624-1) Kit can
be connected to the EX350i 24/42 VAC amphenol
using Remote Control Cable assembly K627- [ ]. LN-
25s with a K431-1 remote kit can be connected to
the 24/42 VAC amphenol using a K432 cable and a
K876 adapter. (See connection diagram S19899) to
connect it to one of the 14-pin amphenols. Or the
K432 cable could be modified with a K867 Universal
Adapter Plug (See connection diagram S19405) to
connect it to the 24/42 VAC 14-pin amphenol.
W ARNING REMOTE
POW ER
OFF
ON
A AMPS
A
V VOL TS
WELD TERMI NA LS
SELECT
OU TP UT LINCOLN ELECTRIC
INVERTEC V350-PRO
W ARNING W ARNING
AV ISO D E PRECAUC
ION
ATTENTION
!
!
!
!
Lorem ips um d olo r s it a met c onsectetuer adipisc ing Lor em ips um do lor s it a me t co nse cte tue r ad ipis cin g elit, ed d iam no nu mmy nibh euismod t inci dun t ut elit , ed dia m n onu mm y n ibh eu ism od t inc idu nt u t
laoreet do lor e m agn a al iquam er at lao ree t do lore m agn a a liqu am era t Lor em ips um do lor sit a me t conse ctet uer adipi sci ng Lor em ips um do lor s it a me t co nse cte tue r ad ipis cin g elit, ed d iam no num my ni bh eu ismod tin cid unt ut elit , ed dia m n onu mm y n ibh eu ism od t inc idu nt u t laor eet d olo re mag na ali qua m er at lao ree t do lore m agn a a liqu am era t Lorem ipsum do lor sit amet consect etuer adi pisci ng
Lor em ips um do lor s it a me t co nse cte tue r ad ipis cin g eli t, e d d iam n onu mm y ni bh eui sm od tin cid un t ut elit , ed dia m n onu mm y n ibh eu ism od t inc idu nt u t lao reet do lore ma gn a a liquam era t lao ree t do lore m agn a a liqu am era t Lor em ipsum dolor sit am et consect etuer adi piscin g Lor em ips um do lor s it a me t co nse cte tue r ad ipis cin g elit, ed d iam no num my nib h eui sm od tin cid unt ut elit , ed dia m n onu mm y n ibh eu ism od t inc idu nt u t lao reet do lor e m agn a a liquam era t lao ree t do lore m agn a a liqu am era t Lor em ipsum dolor sit amet consect etuer adi pisci ng
Lor em ips um do lor s it a me t co nse cte tue r ad ipis cin g elit, ed d iam no num my nibh eui sm od tinc idun t ut elit , ed dia m n onu mm y n ibh eu ism od t inc idu nt u t laor eet d olo re m ag na al iquam era t lao ree t do lore m agn a a liqu am era t Lorem ipsum do lor sit amet consect etuer adi pisci ng
Lor em ips um do lor s it a me t co nse cte tue r ad ipis cin g el it, e d d iam nonu mm y ni bh eui sm od tincidu nt u t elit , ed dia m n onu mm y n ibh eu ism od t inc idu nt u t laor eet do lor e m agna aliquam er at lao ree t do lore m agn a a liqu am era t Lore m i ps um dol or sit ame t c ons ecte tue r ad ipi scing
Lor em ips um do lor s it a me t co nse cte tue r ad ipis cin g
elit , ed dia m n onu mm y n ibh eui smod tin cidun t ut
elit , ed dia m n onu mm y n ibh eu ism od t inc idu nt u t
laoreet dolore magna aliq uam er at lao ree t do lore m agn a a liqu am era t Lorem ipsum do lor sit amet consect etuer adi pisci ng
Lor em ips um do lor s it a me t co nse cte tue r ad ipis cin g
elit, ed dia m n onum my nib h e uis mo d tinc idunt ut
elit , ed dia m n onu mm y n ibh eu ism od t inc idu nt u t laoreet do lore ma gna al iquam era t lao ree t do lore m agn a a liqu am era t Lor em ipsum dolor si t a met consectetu er adipis cing
Lor em ips um do lor s it a me t co nse cte tue r ad ipis cin g
elit, ed diam non um my n ibh eu ism od tinc idun t ut
elit , ed dia m n onu mm y n ibh eu ism od t inc idu nt u t la ore et d olore m agna ali qua m er at lao ree t do lore m agn a a liqu am era t
Lorem ipsum do lor si t am et consecte tuer adi piscing Lor em ips um do lor s it a me t co nse cte tue r ad ipis cin g eli t, e d d iam n onu mmy nib h e uis mo d tin cid un t ut elit , ed dia m n onu mm y n ibh eu ism od t inc idu nt u t lao ree t d olor e ma gna aliqu am er at lao ree t do lore m agn a a liqu am era t Lor em ips um do lor s it a met con se ctet uer adi pis cing Lor em ips um do lor s it a me t co nse cte tue r ad ipis cin g
elit, ed d iam no num my n ibh eu ism od t inci dun t ut elit , ed dia m n onu mm y n ibh eu ism od t inc idu nt u t
laoreet do lore m ag na aliquam era t lao ree t do lore m agn a a liqu am era t Lorem ipsum do lor sit am et consecte tuer adi piscin g Lor em ips um do lor s it a me t co nse cte tue r ad ipis cin g elit , ed dia m n onum my nibh eui smod tincid un t ut elit , ed dia m n onu mm y n ibh eu ism od t inc idu nt u t lao reet do lor e m agna aliquam er at lao ree t do lore m agn a a liqu am era t Lo rem ips um dolor sit ame t co nsect etuer adi pisci ng
Lor em ips um do lor s it a me t co nse cte tue r ad ipis cin g
elit, ed d iam no num my nibh eui sm od tin cidun t ut
elit , ed dia m n onu mm y n ibh eu ism od t inc idu nt u t
laoree t d olo re m agn a al iquam erat lao ree t do lore m agn a a liqu am era t Lorem ipsum dolo r sit a me t consectetue r adipis cing
Lor em ips um do lor s it a me t co nse cte tue r ad ipis cin g
elit, ed diam nonu mmy nibh eui smod tin cid unt ut
elit , ed dia m n onu mm y n ibh eu ism od t inc idu nt u t
laoreet dolore m ag na aliqu am erat lao ree t do lore m agn a a liqu am era t Lo rem ips um dolor sit amet c onsec tetu er ad ipiscing
Lor em ips um do lor s it a me t co nse cte tue r ad ipis cin g
elit , ed diam non ummy nibh eui smod tin cid unt ut
elit , ed dia m n onu mm y n ibh eu ism od t inc idu nt u t
lao reet dol ore ma gna al iqu am era t lao ree t do lore m agn a a liqu am era t Lo re m i psum dolo r sit a met co nsectet ue r ad ipis cing
Lor em ips um do lor s it a me t co nse cte tue r ad ipis cin g
elit, ed diam nonu mm y nibh euismod tin cid un t u t
elit , ed dia m n onu mm y n ibh eu ism od t inc idu nt u t
laoreet dolo re magna al iquam erat lao ree t do lore m agn a a liqu am era t Lor em i psu m d olo r sit amet consec tetu er adip isci ng
Lor em ips um do lor s it a me t co nse cte tue r ad ipis cin g
el it, ed diam no nummy n ibh eui smo d tincidunt ut
elit , ed dia m n onu mm y n ibh eu ism od t inc idu nt u t
lao reet do lore ma gna al iqu am erat lao ree t do lore m agn a a liqu am era t
Lorem ipsum do lor sit ame t co nsec tet uer adip isc ing
Lor em ips um do lor s it a me t co nse cte tue r ad ipis cin g
elit , ed dia m n onummy nibh eui sm od tin cidun t ut
elit , ed dia m n onu mm y n ibh eu ism od t inc idu nt u t
laoree t dolore magna aliqu am erat lao ree t do lore m agn a a liqu am era t Lore m ip sum do lor s it a me t c ons ecte tue r a dipi scing Lor em ips um do lor s it a me t co nse cte tue r ad ipis cin g elit, ed d iam no nu mmy nibh eui smo d tinc idu nt ut elit , ed dia m n onu mm y n ibh eu ism od t inc idu nt u t laoreet dolore ma gna aliquam era t lao ree t do lore m agn a a liqu am era t
GREEN
RED
BLACK
WHITE or BROWN
EX350i
CAUTION
CAUTION