Lincoln Electric IM846 POWER WAVE 405M - Manual (Page 11)

A-2 INSTALLATION
POWER WAVE ® 405M
A-2
SELECT SUITABLE LOCATION
The Invertec POWER WAVE ® 405M will operate in
harsh environments. Even so, it is important that sim-
ple preventative measures are followed in order to
assure long life and reliable operation.
• The machine must be located where there is free cir-
culation of clean air such that air movement in the
back, out the sides and bottom will not be restricted.
• Dirt and dust that can be drawn into the machine
should be kept to a minimum. Failure to observe
these precautions can result in excessive operating
temperatures and nuisance shutdown.
• Keep machine dry. Shelter from rain and snow. Do
not place on wet ground or in puddles.
• DO NOT MOUNT OVER COMBUSTIBLE SURFACES.
Where there is a combustible surface directly
under stationary or fixed electrical equipment,
that surface shall be covered with a steel plate at
least .06”(1.6mm) thick, which shall extend not
less than 5.90”(150mm) beyond the equipment on
all sides.
-----------------------------------------------------------------------
STACKING
POWER WAVE
® 405M cannot be stacked.
TILTING
Place the machine directly on a secure, level surface
or on a recommended undercarriage. The machine
may topple over if this procedure is not followed.
INPUT AND GROUNDING CONNECTIONS
• Only a qualified electrician should connect the
Invertec POWER WAVE ® 405M. Installation should
be made in accordance with the appropriate
National Electrical Code, all local codes and the
information detailed below.
• When received directly from the factory, multiple
voltage machines are internally connected for
400VAC. If 400VAC is the desired input, then the
machine may be connected to the power system
without any setup required inside the machine.
SAFETY PRECAUTIONS
ELECTRIC SHOCK can kill.
• TURN THE INPUT POWER OFF AT
THE DISCONNECT SWITCH BEFORE
ATTEMPTING TO CONNECT OR DIS-
CONNECT INPUT POWER LINES,
OUTPUT CABLES, OR CONTROL CABLES.
• Only qualified personnel should perform this
installation.
• Connect the green or green/yellow lead of the
power cord to ground per U.S.National
Electrical Code.
----------------------------------------------------------------------
WARNING
• Initial 200VAC - 230VAC operation will require an
Input voltage panel setup.
• Open the access panel on the rear of the machine.
• For 200 or 230: Position the large switch to 200-
230.
• For higher voltages: Position the large switch to
greater than 380.
• Move the "A" lead to the appropriate terminal.
POWER CORD CONNECTION
A 10ft.(3.5m) power cord is provided and wired into
the machine. Follow the power cord connection
instructions.
• Incorrect connection may result in equipment
damage.
-----------------------------------------------------------------------
Single Phase Input
Connect green/yellow lead to ground per National
Electrical Code.
Connect blue and brown leads to power.
Wrap blue lead with tape to provide 600V insulation.
Three Phase Input
Connect green/yellow lead to ground per National
Electric Code.
Connect black, blue and brown leads to power.
UNDERCARRIAGE MOUNTINGS
WA RN ING W AR NI NG AV ISO DE PR EC AU CIO N
ATT EN TION
!
!
!
!
Lo rem ips um do lor s it a me t con sec tet ue r ad ipis cing
Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing elit, ed diam no num my nib h e uism od tinc idu nt ut elit, ed dia m n onu mm y n ibh eu ism od t incid unt ut laor eet do lor e m agna aliq uam era t lao ree t do lore m agn a a liqu am era t Lorem ips um dol or s it am et c on sec tet uer adi pisc ing
Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing elit, ed dia m no num my nib h e uism od tin cidu nt u t elit, ed dia m n onu mm y n ibh eu ism od t incid unt ut lao ree t do lore ma gna aliq uam era t lao ree t do lore m agn a a liqu am era t Lor em ips um dol or s it a me t co ns ec tetu er ad ipis cing
Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cin g
elit, ed dia m n onum my nibh eui sm od tinc idu nt ut
elit, ed dia m n onu mm y n ibh eu ism od t incid unt ut laor eet dol ore m agn a a liqu am er at lao ree t do lore m agn a a liqu am era t Lore m ip sum do lor s it am et c ons ectet uer adi pisc ing
Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing
elit, ed dia m n onu mm y n ibh eu ism od tin cidun t ut
elit, ed dia m n onu mm y n ibh eu ism od t incid unt ut lao ree t do lor e m ag na a liquam era t lao ree t do lore m agn a a liqu am era t Lor em ips um do lor s it a met con sec tetu er a dipi scin g
Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cin g
elit, ed dia m n onu mm y ni bh e uism od tinc idu nt u t
elit, ed dia m n onu mm y n ibh eu ism od t incid unt ut lao ree t dol ore ma gna aliqu am er at lao ree t do lore m agn a a liqu am era t Lor em ips um do lor s it a met con sec tetu er a dipi scin g
Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing elit, ed dia m n onu mm y n ibh euis mo d tin cidu nt u t
elit, ed dia m n onu mm y n ibh eu ism od t incid unt ut
lao reet do lor e m agn a a liqu am era t lao ree t do lore m agn a a liqu am era t Lorem ips um do lor sit am et c ons ectet uer adi pisc ing Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing elit, ed dia m n onu mm y n ibh eu ism od t incid unt ut elit, ed dia m n onu mm y n ibh eu ism od t incid unt ut lao ree t do lore m agna aliq uam era t lao ree t do lore m agn a a liqu am era t Lorem ips um dol or s it am et c ons ec tet ue r ad ipis cing Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing elit, ed dia m n on um my nib h e uism od t incid unt ut elit, ed dia m n onu mm y n ibh eu ism od t incid unt ut lao ree t do lore m agna aliq uam er at lao ree t do lore m agn a a liqu am era t Lor em ips um do lor sit am et c on sec tet uer ad ipis cing Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing elit, ed dia m n onum my nib h e uism od tinc idu nt u t
elit, ed dia m n onu mm y n ibh eu ism od t incid unt ut laor eet do lore m agn a a liqu am era t lao ree t do lore m agn a a liqu am era t
Lo rem ips um do lor s it a me t con sec tet ue r ad ipis cing
Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing elit , ed dia m n onum my nib h e uism od tinc idu nt ut elit, ed dia m n onu mm y n ibh eu ism od t incid unt ut laor eet dol ore ma gna aliq uam erat lao ree t do lore m agn a a liqu am era t Lor em ips um dol or s it a me t co nse cte tuer ad ipis cing Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing elit, ed diam no num my nib h e uism od tinc idu nt u t elit, ed dia m n onu mm y n ibh eu ism od t incid unt ut laor eet do lore m agna aliq ua m e rat lao ree t do lore m agn a a liqu am era t Lore m ip sum do lor sit am et c ons ectet uer adi pisc ing
Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cin g elit, ed dia m n onum my nib h eui sm od tinc idu nt u t elit, ed dia m n onu mm y n ibh eu ism od t incid unt ut lao ree t do lore m agn a al iqu am era t lao ree t do lore m agn a a liqu am era t Lore m ip sum dol or s it a me t con sec tetu er a dip iscin g Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cin g elit, ed dia m non um my nibh eui sm od t incid unt ut elit, ed dia m n onu mm y n ibh eu ism od t incid unt ut lao ree t dol ore m agn a a liqu am erat lao ree t do lore m agn a a liqu am era t Lorem ips um dolor sit a me t co nse cte tuer ad ipis cing
Lore m ip sum do lor sit a me t co nse cte tue r ad ipis cin g
elit , ed dia m non um my nib h e uism od tinc idu nt u t
elit, ed dia m n onu mm y n ibh eu ism od t incid unt ut
la ore et d olo re ma gna aliq uam era t lao ree t do lore m agn a a liqu am era t Lo rem ipsu m d olo r sit am et c ons ecte tue r ad ipis cing
Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing
elit , ed diam non um my nib h eu ism od t incid unt ut
elit , ed dia m n onu mm y n ibh eu ism od t incid unt ut
lao ree t dol ore m ag na a liqu am era t lao ree t do lore m agn a a liqu am era t Lorem ips um do lor sit a me t co nse cte tue r ad ipis cing
Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing
elit , ed dia m non um my nib h e uism od tinc idu nt u t
elit, ed dia m n onu mm y n ibh eu ism od t incid unt ut
laor eet dol ore m agna aliqu am era t lao ree t do lore m agn a a liqu am era t Lor em ips um dolo r si t ame t co nse ctet uer adip iscing
Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing
elit, ed diam no num my nib h e uis mod tin cidun t ut
elit, ed dia m n onu mm y n ibh eu ism od t incid unt ut
lao reet do lore ma gna aliqu am era t lao ree t do lore m agn a a liqu am era t
Lore m ips um do lor s it a met co ns ecte tue r ad ipis cing Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing elit , ed diam no num my nibh eu ism od t incid unt ut elit, ed dia m n onu mm y n ibh eu ism od t incid unt ut laor eet dol ore m agn a a liqua m e rat lao ree t do lore m agn a a liqu am era t Lor em ips um do lor sit a met co ns ecte tue r ad ipis cing
Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing elit, ed dia m n onu mm y n ibh eui sm od tinc idu nt u t elit, ed dia m n onu mm y n ibh eu ism od t incid unt ut lao ree t do lor e m agn a a liqua m e rat lao ree t do lore m agn a a liqu am era t
W ARN IN G RE M OT E
PO W ER
OF F
ON
P O W E R W A V E 3 5 5
GREEN / YELLOW
BLUE
BLACK
BROWN
5.50
10.0 10.00
MOUNTING HOLE LOCATIONS
M19527
1/4- 1/4-20 NUT (4 PLACES)
NOTE: MOUNTING SCREWS CA
10/01 10/01
N NOT PROTRUDE MORE THAN
0.5 IN 0.5 INCHES INSIDE THE MACHINE. CHES INSIDE THE MACHINE.
11.84
3.50
CAUTION
CAUTION