Watlow Series EHG SL10 Integrated Temperature Controller - Manual (Page 9)

Watlow Controls 9 EHG SL10 User’s Guide
Specifications
Power
• Isolated Universal Power Supply: 85 to 264V Å (ac)
50/60Hz
• Up to 2400 W with 10A switching capability
NO-ARC Relay
• 10A switching
• 4.5 million cycles
Environmental
• Ambient operating temperature range 0 to 70 °C (32 to
158 °F)
Agency Approvals
• UL ® 1998/C-UL ®
• CE 60730
• SEMI-S2
Ordering Information
Series EHG SL10 Integrated Temperature Controller
EHG2- CNTL-_ _ _ _
0000 basic control (purchased only as part of a heater assembly)
EHG2- MODU-_ _ _ _
DISP with display module
COMS with communications module
DSCM with display & communications module
Additional Power Cables
4800-0012: jumpered long cable
4800-0022: terminated long cable
4800-0011: jumpered short cable
4800-0021: terminated short cable
Declaration of Conformity
Series EHG SL10
Watlow Winona, Inc.
1241 Bundy Blvd.
Winona, MN 55987 USA
Declares that the following product:
Designation:
Series EHG SL10
Model Numbers: EHG2-CNTL-(0000, DISP, COMS, DSCM)
Classifi cation: Electronic Thermostat with Integrated Temperature Limiter Protective
Control, Control Relay = 2CK, Limit Relay = 2JK, TA Relay = 2B
Installation Category II, Pollution degree 2, Software Class B
Rated Supply Source: 100 to 240 V~ (ac), 50 or 60 Hz
IP Code IP20
Rated Power: 5 VA Unit power, 10 A Resistive Heater Load
Meets the essential requirements of the following European Union Directives by using the relevant
standards show below to indicate compliance.
89/336/EEC Electromagnetic Compatibility Directive
EN 60730-1 2001 + A1-A4 Automatic electrical controls for household and similar
use
EN 60730-2-9 2002 + A1 - Temperature Sensing Controls, Class B Emissions
EN 61000-4-2 1996 + A1, A2 Electrostatic Discharge Immunity
EN 61000-4-3 2006 Radiated Field Immunity
EN 61000-4-4 2004 Electrical Fast-Transient / Burst Immunity
EN 61000-4-5 2006 Surge Immunity
EN 61000-4-6 1996 + A1, A2, A3 Conducted Immunity
EN 61000-4-8 1994 + A1 Power frequency magnetic fi eld immunity
EN 61000-4-11 2004 Voltage Dips, Short Interruptions and Voltage
Variations Immunity
EN 61000-4-28 2000 Variation of power frequency immunity – Level 2
EN 61000-3-2 2006 Harmonic Current Emissions
EN 61000-3-3 2005 Voltage Fluctuations and Flicker
SEMI F47 2000 Specifi cation for Semiconductor Processing Equipment
Voltage Sag Immunity – Figure R1-1
2006/95/EC Low-Voltage Directive
EN 61010-1 2001 Safety Requirements of electrical equipment for mea-
surement, control and laboratory use. Part 1: General
requirements
EN 60730-1
2001 + A1-A4 Automatic electrical controls for household and similar
use
EN 60730-2-9 2002 + A1 - Temperature Sensing Controls
UL 1998 ED.2 Software in programmable components.
Raymond D. Feller III Winona, Minnesota, USA
Name of Authorized Representative Place of Issue
General Manager February 2009
Title of Authorized Representative Date of Issue
Signature of Authorized Representative
Warranty
The Series EHG SL10 is warranted to be free of defects in material
and workmanship for 24 months after delivery to the first purchaser
for use, providing that the units have not been misapplied. Since
Watlow has no control over their use, and sometimes misuse, we
cannot guarantee against failure. Watlow’s obligations hereunder, at
Watlow’s option, are limited to replacement, repair or refund of pur-
chase price, and parts which upon examination prove to be defective
within the warranty period specified. This warranty does not apply to
damage resulting from transportation, alteration, misuse or abuse.
WARNING: To avoid damage to property and equipment, and/or
injury or loss of life, use National Electric Code (NEC) standard
wiring practices to install and operate the Series EHG SL10. Fail-
ure to do so could result in such damage, and/or injury or death.