beautypg.com

Warning, Rw front back, Approx. 45 – Roberts Gorden Caribe CGTH-50 User Manual

Page 37: Cgth-series

background image

SECTION 6: E

LECTRICAL

S

ERVICE

I

NSTALLATION

31

SECTION 6: ELECTRICAL SERVICE INSTALLATION
6.1 System Requirements

The CGTH-Series heater requires a grounded three-
prong electrical outlet to be installed within 18" (46
cm) of the rear surface of the heater's burner. It is rec-
ommended that the outlet for the heater be ceiling-
mounted and should be on a dedicated circuit. DO
NOT use an electrical extension cord to operate the
heater.

Heater Rating: 120V, 60 Hz, Single Phase, 1A

6.2 Grounding

The heater must be electrically grounded in accor-
dance with the following codes: United States: Refer
to National Electrical Code, ANSI/NFPA-70 - latest
revision. Wiring must conform to the most current
National Electrical Code and local ordinances. Can-
ada: Refer to Canadian Electrical Code, CSA C22.1
Part 1 - latest revision.

6.3 Important Notes

1. The CGTH-Series heater is controlled by a low volt-

age (24V AC) thermostat supplied with the heater.
The control transformer located inside the burner
supplies the necessary electrical power to operate

the thermostat. No other electrical power to the
thermostat is required.

2. The wire for connecting the thermostat to the

heater is not supplied. Refer to the installation
instructions supplied with the thermostat for cor-
rect wire sizing.

6.4 Thermostat Placement

For best results, locate the thermostat as follows:

• Mount the thermostat on an interior wall whenever

possible.

• Mount the thermostat approximately 60" (1524

mm) from the floor.

• Mount the thermostat so that it is shielded from

the heat that is radiated from the heater.

• Mount the thermostat over the thermostat tag that

is provided in the accessories bag. The thermo-
stat tag contains important safety information and
must be used.

6.5 Thermostat Installation

1. Connect thermostat wiring to the thermostat as

follows:

A. Attach one wire of the thermostat wires to the

"R" terminal on the rear of the thermostat;
attach the remaining wire to the "W" terminal
(See Figure 30).

B. Peel off backing of adhesive strips on the rear

surface of the thermostat tag and position the
tag against the wall; secure thermostat over
tag using two screws.

FIGURE 30: Thermostat Installation

Electrical Shock Hazard

Plug heater into grounded three-

prong ceiling receptacle.
Do not cut or remove the grounding

prong from this plug.
Do not use with an extension cord.
Failure to follow these instructions

can result in death or electrical

shock.

WARNING

°F 40 50 60 70

°C 5 10 15 20

OFF

● ● ● ● ●

R

W

FRONT

BACK

Fire Hazard

Some objects will catch fire or

explode when placed close to

heater.

Keep all flammable objects,

liquids and vapors the required

safe distances away from heater.

Keep children, clothing and

furniture away from the heater.

Failure to follow these

instructions will result in death,

injury or property damage.

WARNING

Printed in U.S.A./Imprimé aux Etats-Unis

This thermostat controls your overhead tube heater. Keep burner, control compartment and reflector clean. Read

your CGTH-Series Use and Care Manual (P/N 180101NA or GH80101NA) and follow all Safety Requirements which

include checking your heater monthly. Installation, Service and Annual Inspection must be done by a contractor

qualified in the installation and service of gas-fired heating equipment. Please call (716) 852-4400 (USA) or (905)

945-5403 (Canada) if you need a manual or have questions.
Ce thermostat commande votre radiateur. Gardez le module de contrôle et le reflécteur propres. Lisez le manuel

d’utilisation et d’entretien CGTH-Series (P/N 180101NA ou GH80101NA) et respectez tous les conseils de sécurité,

notamment le contrôle mensuel du radiateur. L’installation, l'entretien et l’inspection annuelle doivent être effectués

par un agent agréé. Veuillez nous contactez au 716-852-4400 (USA) ou au 905-945-5403 (Canada) pour toutes

questions ou demandes de manuel.

MOUNT

THERMOSTAT

HERE

MONTER LE

THERMOSTAT ICI

ATTENTION

Risque d'incendie

Certains objets placés près du

radiateur peuvent s'enflammer ou

exploser.

Tenir tous les objets, iquides et

vapeurs inflammables à la

distance de sécurité requise du

radiateur.

Surveiffer les enfants. Gardes les

vêtements, les meubles loin de

l'appareil.

Le non-respect de ces consignes

peut causer dommage au matériel.

Required Safe Distances from Combustibles

Distances de Dégagement par Rapport aux Combustibles

Horizontal Mount

Montage Horizontal

45° Mount

Montage à 45°

24" Min. (61 cm)

A

A

D

D

E

E

A

A

FF

Approx. 45 °

F

B

A

C

24" Min. (61 cm)

B

Rating Tag

Éttiquette de

Classement

by

CGTH-Series

®

NOTES: 1. Toutes les dimensions sont mesurées à partir du réflecteur.

2. Les chiffres noirs sont en pouces.

Les chiffres oranges

sont en centimètres.

3. Vous devrez connaître le numéro de votre modèle. Il se

trouve sur l’étiquette de classement. (Voir le dessin du

montage horizontal pour l’emplacement de l’étiquette de

classement).

Model

A B

C

D

EF

CGTH-30

4 16 36 28 34 6

CGTH-40

4 18 48 30 34 6

CGTH-50

4 20 48 32 36 6

Modèle

A B

C

D

EF

CGTH-30 11 41 92 72 87 16
CGTH-40 11 46 122 77 87 16
CGTH-50 11 51 122 82 92 16

©

www.rg-inc.com

P/N 91037903 Rev F

NOTES: 1. All dimensions are from the reflector.

2. Black numerals are in inches.

Orange numerals are in

centimeters.

3. Know your model number. Model number is found on the

rating tag. (See horizontal mount drawing for location of

rating tag).

This manual is related to the following products: