Lincoln Electric POWER WAVE 355/405 SVM159-A - Manual (Page 12)

A-4 A-4
POWER WAVE 355/405 Retur
n to Section TOC
Retur
n to Section TOC
Retur
n to Section TOC
Retur
n to Section TOC
Retur
n to Master TOC
Retur
n to Master TOC
Retur
n to Master TOC
Retur
n to Master TOC
INSTALLATION
ELECTRIC SHOCK can kill.
• TURN THE INPUT POWER OFF AT
THE DISCONNECT SWITCH BEFORE
ATTEMPTING TO CONNECT OR DIS-
CONNECT INPUT POWER LINES, OUTPUT
CABLES, OR CONTROL CABLES.
• Only qualified personnel should perform this
installation.
• Connect the green/yellow lead of the power
cord to ground per U.S.National Electrical Code.
----------------------------------------------------------------------
WARNING
SAFETY PRECAUTIONS
SELECT SUITABLE LOCATION
In order to assure long life and reliable operation,
the owner of this machine should follow these sim-
ple preventative measures:
• The machine must be located where there is free cir-
culation of clean air such that air movement in the
back, out the sides and bottom will not be restricted.
• Dirt and dust that can be drawn into the machine
should be kept to a minimum. Failure to observe
these precautions can result in excessive operating
temperatures and nuisance shutdown.
• Keep machine dry. Shelter from rain and snow. Do
not place on wet ground or in puddles.
• DO NOT MOUNT OVER COMBUSTIBLE SURFACES.
Where there is a combustible surface directly under
stationary or fixed electrical equipment, that surface
shall be covered with a steel plate at least .06”(1.6mm)
thick, which shall extend not less than 5.90”(150mm)
beyond the equipment on all sides.
STACKING
POWER WAVE 355/405 cannot be stacked.
TILTING
Place the machine directly on a secure, level surface
or on a recommended undercarriage. The machine
may topple over if this procedure is not followed.
INPUT AND GROUNDING CONNECTIONS
• Only a qualified electrician should connect the
POWER WAVE 355/405. Installation should be
made in accordance with the appropriate National
Electrical Code, all local codes and the information
detailed below.
• When received directly from the factory, multiple volt-
age machines are internally connected for the highest
voltage. Always double-check connections before
powering up the machine.
• Initial 200VAC - 415VAC and 575VAC operation will
require an Input voltage panel setup.
CAUTION
• Open the access panel on the rear of the machine.
• For 200 or 230: Position the large switch to 200-
230.
For higher voltages: Position the large switch to
380-575.
• Move the "A" lead to the appropriate terminal.
POWER CORD CONNECTION
A power cord is provided and wired into the machine.
Follow the power cord connection instructions.
•Incorrect connection may result in equipment
damage.
Single Phase Input (PW 355)
Connect green lead to ground per National Electrical
Code.
Connect black and white leads to power.
Wrap red lead with tape to provide 600V insulation.
Three Phase Input (PW 355)
Connect green lead to ground per National Electric
Code.
Connect black, red and white leads to power.
Single Phase Input (PW 405)
Connect green/yellow lead to ground per National
Electrical Code.
Connect blue and brown leads to power.
Wrap black lead with tape to provide 600V insulation.
Three Phase Input (PW 405)
Connect green/yellow lead to ground per National
Electric Code.
Connect black, blue and brown leads to power.
W AR NIN G RE M OT E
PO W ER
OF F
ON
A A M P S
A
V V O LT S
W ELD TE RM IN ALS SE LE CT
O U TP U T LIN CO LN EL EC TR IC IN VE RT EC V 35 0-P RO
W AR NING W AR NIN G AVIS O D E PRE CAU CIO N
ATTEN TIO N
!
!
!
!
Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing
Lo rem ipsu m dol or sit amet con sect etu er adi pis cing elit, ed dia m n onu mm y n ibh eu ism od t incid unt ut elit , ed dia m no num my n ibh eui smo d ti ncidunt ut lao ree t do lore m agn a a liqu am era t laor ee t dolore ma gna aliquam erat Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing Lorem ipsum do lor s it ame t cons ect etue r adipiscing elit, ed dia m n onu mm y n ibh eu ism od t incid unt ut
elit, e d d iam nonum my nib h euism od ti ncidu nt ut lao ree t do lore m agn a a liqu am era t laoreet dolore m agn a a liquam era t Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing Lorem ipsu m d olo r si t a met cons ect etue r adipi sc ing elit, ed dia m n onu mm y n ibh eu ism od t incid unt ut
elit , ed diam nonu mm y n ibh e uismo d tinc idun t u t lao ree t do lore m agn a a liqu am era t lao reet do lore m ag na aliq uam era t Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing Lor em ips um dolor sit amet cons ect etuer ad ipiscing elit, ed dia m n onu mm y n ibh eu ism od t incid unt ut
el it, ed diam no nummy n ibh e uismo d t inci dunt ut lao ree t do lore m agn a a liqu am era t laoreet dol ore m agn a al iquam era t Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing Lor em ipsu m dolor sit amet consecte tuer a dipi sci ng elit, ed dia m n onu mm y n ibh eu ism od t incid unt ut
elit, ed d iam nonummy n ibh eu ismod ti nci dunt ut lao ree t do lore m agn a a liqu am era t laoreet d olor e m agna aliquam era t Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing Lor em ipsu m d olor sit amet con sectetuer adi pisci ng elit, ed dia m n onu mm y n ibh eu ism od t incid unt ut elit, e d d iam nonum my nibh euismo d ti ncidun t ut lao ree t do lore m agn a a liqu am era t laoreet dolore ma gna aliq uam erat Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing Lorem ips um dolor sit a met con se ctetuer a dipis cin g elit, ed dia m n onu mm y n ibh eu ism od t incid unt ut el it, ed di am no nummy n ibh eu ismod tin cidu nt ut lao ree t do lore m agn a a liqu am era t laore et dolore ma gna al iqu am erat Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing Lo rem i psu m do lor sit am et co nsectetuer a dip isci ng elit, ed dia m n onu mm y n ibh eu ism od t incid unt ut el it, e d d iam no nummy n ibh euismod tin cidunt ut lao ree t do lore m agn a a liqu am era t laore et do lore magna al iqu am e rat Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing Lor em ipsu m d olor si t a met consectetuer a dip iscin g elit, ed dia m n onu mm y n ibh eu ism od t incid unt ut elit, ed diam no nu mm y ni bh eu ism od tin cid unt ut lao ree t do lore m agn a a liqu am era t laoreet dolo re magna al iqu am er at
Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing Lore m ipsum d olor s it a met consectetuer adi pis cing elit, ed dia m n onu mm y n ibh eu ism od t incid unt ut
elit, ed di am nonummy n ibh e uismod ti ncidun t ut lao ree t do lore m agn a a liqu am era t lao ree t do lor e mag na ali quam er at Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing
Lore m ip sum do lor si t am et con sec tetuer adipisc ing elit, ed dia m n onu mm y n ibh eu ism od t incid unt ut el it, e d diam nonum my nib h e uismo d tinc idun t u t lao ree t do lore m agn a a liqu am era t laor eet d olore m agn a aliquam erat Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing Lo rem ipsum dolo r sit am et co ns ec tetuer adipi sci ng
elit, ed dia m n onu mm y n ibh eu ism od t incid unt ut
elit , ed di am nonu mmy ni bh euis mod ti nci dunt ut lao ree t do lore m agn a a liqu am era t laore et do lore ma gna ali qu am erat Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing Lo rem ips um dolor sit a met consec tetuer adip isci ng elit, ed dia m n onu mm y n ibh eu ism od t incid unt ut elit, ed diam nonummy ni bh euismod tin cidunt ut lao ree t do lore m agn a a liqu am era t la oreet dol ore m ag na aliqu am erat Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing
Lo rem ipsum dolor sit amet con se ctetuer adipiscing elit, ed dia m n onu mm y n ibh eu ism od t incid unt ut
elit, ed d iam nonummy nibh euism od t inci dunt ut
lao ree t do lore m agn a a liqu am era t laoreet dolo re mag na aliqua m erat Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing
Lo rem ipsu m dolo r sit amet consectetuer a dip isc ing
elit, ed dia m n onu mm y n ibh eu ism od t incid unt ut
elit, ed diam nonummy ni bh e uismod tincidun t ut
lao ree t do lore m agn a a liqu am era t la ore et dolore magna aliquam erat Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing
Lor em ips um dolo r s it amet consectetuer adipiscing elit, ed dia m n onu mm y n ibh eu ism od t incid unt ut
el it, e d d iam nonumm y n ibh eu ismod t inc idu nt ut
lao ree t do lore m agn a a liqu am era t laoreet d olo re ma gna aliqu am era t Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing
Lore m ipsu m d olo r sit amet consectet uer ad ipiscing
elit, ed dia m n onu mm y n ibh eu ism od t incid unt ut
elit , e d d iam nonummy nibh eu ismo d tincidu nt ut
lao ree t do lore m agn a a liqu am era t la oreet dolor e magna aliquam erat
Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing
Lo rem ipsum do lor sit amet consec tetu er ad ipi sc ing elit, ed dia m n onu mm y n ibh eu ism od t incid unt ut elit, e d diam no nu mmy nibh euismo d tincidunt ut lao ree t do lore m agn a a liqu am era t lao reet d olore m agna aliquam erat Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing Lo rem ipsum dolo r sit ame t co nsect etu er adi pis cing elit, ed dia m n onu mm y n ibh eu ism od t incid unt ut
eli t, ed diam n on um my ni bh eu ismod tinci dunt ut lao ree t do lore m agn a a liqu am era t la oreet do lore magna al iquam er at
CAUTION
Machine
PW 355
PW 405
Cord Length
10 Feet
5 Meters
Lead Color Single Phase Three Phase
Connect to
ground per NEC
Power Lead
Power Lead
Power Lead
Connect to
ground per NEC
Power Lead
Power Lead
Tape, provide
600V insulation
Green
Black
White
Red