KTM 450 SMR - Manual (Page 55)

MAINTENANCE WORK ON CHASSIS AND ENGINE
53
Removing the seat
500080-10
ಥ Remove screw ‘ . Lift up the seat at the rear, pull it back and then remove from
above.
Mounting the seat
500068-01
ಥ Check parts for damage and wear. Replace damaged or worn parts.
ಥ Hook the front of the seat into the flange adapter of the fuel tank, lower the rear of
the seat and simultaneously push it forwards.
ಥ Make sure that the seat is correctly locked in.
ಥ Mount and tighten the screw of the seat fixing.
Specification
Remaining screws, chassis M6 10 ‘Nm
(7.38 ‘lbf‘ft)
Dismounting the fuel tank ‘
x
ಥ Remove the seat. ( P. 53)
500219-10
Danger
Fire hazard ಗFuel can easily catch fire.
ಥ Never fill up the vehicle near open flames or burning cigarettes, and
always switch off the engine first. Be careful that no fuel is spilt, espe-
cially on hot vehicle components. Clean up spilt fuel immediately.
ಥ Fuel in the fuel tank expands when warm and can escape if the tank is
overfilled. See specifications on filling up with fuel.
Warning
Danger of poisoning ಗFuel is poisonous and a health hazard.
ಥ Avoid contact between fuel and skin, eyes and clothing. Do not inhale
fuel vapors. If fuel gets into your eyes, rinse immediately with water and
contact a doctor. Wash affected skin areas immediately with soap and
water. If fuel is swallowed, contact a doctor immediately. Change cloth-
ing that has come into contact with fuel. Store fuel in a suitable canister
according to regulations and keep it out of the reach of children.
ಥ Turn off the fuel tap and pull off the fuel hose.
ಥ Remove screws ‘ with collar sleeve.
500066-10
ಥ Remove screw ‘ with collar sleeve.
ಥ Remove the tube from the fuel tank vent line.