DR Power RapidFire 6 HP Subaru (Aug 2011 - Sept 2012) - Manual (Page 13)

CONTACT US AT www.DRpower.com 13
Chapter 4: Maintaining The DR RAPIDFIRE LOG SPLITTER
Regular maintenance is the way to ensure the best performance and long life of your machine. Please refer to this manual and the
engine manufacturer's owner's manual for maintenance procedures. Service intervals listed in the checklist below supersede
those listed in the engine manufacturer's owner's manual.
Regular Maintenance Checklist
P ROCEDURE B EFORE E ACH U SE E VERY 2-1/2 H OURS E VERY 25 H OURS E VERY 100 H OURS
Check Engine Oil Level ▲
Check General Equipment Condition ▲
Check Wedge for Sharpness ▲
Grease Surface of Slide Rail ▲
Check Belts ▲
Grease Rack and Pinion ▲*
Check Tire Pressure ▲
Clean Engine Exterior and Cooling
Fi ▲
Change Engine Oil 1 st time 5 hours ▲
Replace Air Filter ▲
Replace Spark Plug ▲
*Or 5 cord of wood
Engine Service
Refer to the engine manufacturer’s manual for engine maintenance.
Lubrication
All Bearings of your Splitter are sealed units and should have sufficient
lubricant to last the life of your machine with normal use.
No lubrication is required between the Carriage Bearing and the Frame. This
area must be kept free of lubricant to ensure proper operation of the Splitter
(Figure 18).
Greasing the Rack and Pinion
Tools and Supplies needed:
 All Purpose Grease
 Rubber Gloves

Two 7/16" Wrenches
1. Tie a String on the end loop of the return Spring and carefully (due to
spring tension) remove the Spring from the Bolt threads and hold the
string as you let it retract back under the Belt Guard (Figure 19). Repeat
for the Spring on the other side of the Frame.
2. Pull the Carriage assembly out until it is near the Wedge.
No Grease
Under Here
Figure 18
Before performing any maintenance procedure or inspection, stop the engine, wait five (5) minutes to allow all parts to cool.
Disconnect the spark plug wire, keeping it away from the spark plug. Disconnect the Battery Terminals (Electric start only).
Return Spring
Figure 19
String