beautypg.com

Resumption of service, Maintenance routine diagram, Inspection and maintenance – Baja Motorsports DR125 Operator's Manual User Manual

Page 32

background image

29

RESUMPTION OF SERVICE

1. Remove the covering and clean the vehicle. Change the lubricating oil if

the vehicle has been off service for more than 4 months.

2. Charge the battery, if applicable, and remount it.

3. Drain off the anti-rust solution from the fuel tank, followed by filling fuel

therein to the required level.

4. Prior to driving, test the vehicle at a low speed in a safe place.

MAINTENANCE ROUTINE DIAGRAM

The vehicle should be under good maintenance as specified in the following

table, where:

“I” means: Check, cleaning, adjustment, lubrication and/or replacement

are needed
“C” means: Cleaning is needed.
“R” means: Replacement is needed.
“A” means: Adjustment is needed.

“L” means: Lubrication is needed.

“*” means: This item of maintenance should be carried out at a service

center. It may be also done by the user with reference to this manual provided

special tools and authorized spare parts are used. The user must also be

capable of completing the procedure.
“**” means: This item can only be carried out by an authorized service center

in order to ensure safety.
Notes:

1. Maintenance should be conducted more frequently when the motorcycle

is driven in dusty areas.

2. When the vehicle has exceeded the maximum figures specified in the

table, maintenance should be still cycled according to the intervals of

mileage stated herein.

INSPECTION AND MAINTENANCE

It is very important to inspect and maintain your DR125/DR150 regularly.

Follow the guidelines in the chart. The intervals between periodic

services in months are shown. At the end of each interval be sure to

perform the maintenance listed.