Resumption of service after storage, Table of torque of fasteners – Baja Motorsports DR125 Operator's Manual User Manual
Page 31

28
RESUMPTION OF SERVICE AFTER STORAGE
1. Remove the covering and remove the wooden blocks used in storing the
vehicle. Change the engine oil if the vehicle has been out of service for
over 4 months.
2. Drain off the remaining atomized anti-rust oil from the fuel tank, followed
by filling it with fresh gasoline therein.
3. Prior to driving, all the required check-ups must be made. It is better
to drive it at a low speed in an open area to test its performance before
normal operation.
TABLE OF TORQUE OF FASTENERS
Ser.
No.
Fastener
Torque (Newton/m)
(Foot/lb)
1
Nut for tightening upper joining plate
of front fork with vertical tube
40-50Nm (30-37 ft.lb.)
2
Nuts for fixing engine
20-25Nm (15- 18 ft.lb.)
3
Bolt for tightening upper joining plate
of front fork with shock absorber
15-20Nm (11-15 ft.lb.)