Avalon Firestyles DVL Insert EF-2002 to 2005 - Manual (Page 35)

Optional Equipment
3 5
Travis Industries 4 0 4 1 0 2 8 1 0 0 - 0 1 1 5 1
3 Install the firebacks following the directions below.
a
b
Remove the screw on the back wall of the firebox.
c Rest the upper rear fireback on top of the rear
fireback brace.
d
5/16" Nutdriver
Slide the rear fireback brace over the lower rear
fireback (note how the joggle tilts forward). Place
them against the back wall of the firebox and
attach with the screw removed in step a.
Secure the upper rear fireback by installing the upper rear fireback clip
over the bolts (do not tighten the bolts until the baffle is replaced).
The rear fireback rests on this ledge at the rear of the firebox.
Secure the side firebacks by attaching the fireback clips to the
firebox with the screws removed in step “e”.
Make sure the
notches on the side
firebacks fit into the
grooves on the
firebox floor.
Side Fireback Clip
Remove the screws on both
side walls of the firebox.
f
e
4 Replace the baffle removed in step 2.