Vortech 1996-2000 5.7L Vortec Truck/SUV User Manual

Page 19

P/N: 4GM020-010

14AUG00 V 1.2

(Vortec 350-2 )4GM

12. FINAL CHECK

A. If your vehicle has gone over 10,000 miles

since its last spark plug change, you will
need to change the spark plugs now before
test driving the vehicle.

B. Check all fittings, nuts, bolts and clamps for

tightness. Pay particular attention to oil and
fuel lines around moving parts, sharp edges
and exhaust system parts. Make sure all
wires and lines are properly secured with
clamps or tie wraps. (See

Fig. 12-a

C. Check all fluid levels, making sure that your

tank(s) is/are filled with 92 octane or higher
fuel before commencing test drive.

D. Start engine and allow to idle a few minutes,

then shut off.

Recheck to be sure that no hoses, wires, etc.
are near exhaust headers or moving parts
and for signs of any fluid leakage.

PLEASE TAKE SPECIAL NOTE: Operating
the vehicle without all sub assemblies com-
pletely and properly installed and working
may cause FAILURE OF MAJOR ENGINE
COMPONENTS.

G. Test drive the vehicle.
H. Read the STREET SUPERCHARGER SYS-

TEM OWNER'S MANUAL AND RETURN THE
WARRANTY REGISTRATION FORM within
thirty (30) days of purchasing your super-
charger system to qualify.

Fig. 12-a

WARNING: Do not attempt to operate

the vehicle until ALL
components are installed
and ALL operations are
completed including final
check.