Generac 02010-1 - Manual (Page 4)

SAFETY RULES
Safety Rules
PRIMEPACT 50 Recreational Vehicle Generator
SAVE THESE INSTRUCTIONS - The manufacturer suggests that these rules for safe
A operation be copied and posted in potential hazard areas of the recreational vehicle. Jk
Safety should be stressed to all operators and potential operators of this equipment.
WARNING:
The engine exhaust from this product
contains chemicals known to the state
of California to cause cancer, birth
defects or other reproductive harm.
WARNING:
This product contains or emits chemicals
known to the state of California to cause
cancer, birth defects or other reproductive harm.
Study these SAFETY RULES carefully before
installing, operating or servicing this equipment.
Become familiar with this manual and with the unit.
The generator can operate safely, efficiently and reli­
ably only if it is properly installed, operated and main­
tained. Many accidents are caused by failing to follow
simple and fundamental rules or precautions.
Generac cannot possibly anticipate every possible cir
cumstance that might involve a hazard. The warn­
ings
in this manual, and on tags and decals
affixed to the unit, are, therefore, not all-inclusive. If
you use a procedure, work method or operating tech­
nique Generac does not specifically recommend, you
must satisfy yourself that it is safe for you and others.
You also must make sure the procedure, work
method or operating technique that you choose does
not render the generator unsafe.
DANGER
A
Despite the safe design of this generator,
operating this equipment imprudently, neglecting
its maintenance or being careless can cause
possible injury or death. Permit only responsible
and capable persons to operate or maintain this
equipment.
Potentially lethal voltages are generated by
these machines. Ensure all steps are taken to
render the machine safe before attempting to
work on the generator.
Parts of the generator are rotating and/or hot
during operation. Exercise care near running
generators.
m GENERAL HAZARDS ^
For safety reasons, Generac recommends
that the installation, initial start-up and mainte­
nance of this equipment is carried out by a
Generac Authorized Service Dealer.
The engine exhaust fumes contain carbon monox­
ide, which can be DEADLY. This dangerous gas, if
breathed
in sufficient concentrations, can cause
unconsciousness or even death. This exhaust sys­
tem must be installed properly, in strict compli­
ance
with applicable codes and standards.
Following installation, you must do nothing that
might render the system unsafe or in noncompli­
ance with such codes and standards. The genera­
tor compartment must be completely vapor sealed
from the vehicle interior. There must be no possi­
bility of exhaust fumes entering the vehicle interi­
or. Never operate this equipment with a leaking or
defective exhaust system.
Keep hands, feet, clothing, etc., away from drive
belts, fans, and other moving or hot parts. Never
remove any drive belt or fan guard while the unit is
operating.
Adequate, unobstructed flow of cooling and venti­
lating air is critical to correct generator operation
and is required to expel toxic fumes and fuel
vapors from the generator compartment. Without
sufficient
cooling airflow, the engine/generator
quickly overheats, which causes serious damage to
the generator. Do not alter the installation or per­
mit even partial blockage of ventilation provisions,
as this can seriously affect safe operation of the
generator.
When working on this equipment, remain alert at
all times. Never work on the equipment when you
are physically or mentally fatigued.
Inspect the generator regularly, and contact your
nearest Generac Authorized Service Dealer immedi­
ately for parts needing repair or replacement.
Before performing any maintenance on the genera­
tor, disconnect its battery cables to prevent acci­
dental start up. Disconnect the cable from the bat­
tery post indicated by a NEGATIVE, NEG or (-)
first. Reconnect that cable last.
Never use the generator or any of its parts as a
step. Stepping on the unit can stress and break
parts, and may result in dangerous operating con­
ditions from leaking exhaust gases, fuel leakage,
oil leakage, etc.
Generac® Power Systems, Inc.