Winco WC6000HE/D - Manual (Page 13)

13 3041-00 60706-35
b. Receptacles - Quality receptacles have been
utilized. If a receptacle should become cracked
or otherwise damaged, replace it. Using dam-
aged or cracked receptacles can be both dan-
gerous to the operator and destructive to the
equipment.
CLEANING
Remove dirt and debris with a cloth or brush. DO
NOT use high pressure spray to clean either the
engine or the generator. This high pressure spray
could contaminate the fuel system and the genera-
tor components.
1. Keep the air inlet screen on both the engine and
generator free of any dirt or debris to insure proper
cooling. At least yearly, remove the blower housing
on the engine and clean the chaff and dirt out of the
engine cooling fins and flywheel. Clean more often
if necessary. Failure to keep these areas clean may
cause overheating and permanent damage to the
unit.
2. Periodically clean the muffler area to remove all
grass, dirt and combustible debris to prevent a fire.
3. On engine mufflers equipped with spark arrest-
ers, the spark arrester must be removed every 50
hours for cleaning and inspection.
Replace if damaged
TROUBLESHOOTING
PROBLEM (SYMPTOMS) POSSIBLE
CAUSES
———————————————————————
Won’t Start *Low Oil Level.
*Fouled spark plug.
*Out of fuel.
*Start switch in Off position.
*Fuel valve turn off.
*Plugged fuel filter.
*Blown fuse in key switch
———————————————————————
Voltage too low *Engine speed is too low.
*Generator overloaded.
*Defective stator.
*Defective rotor (field).
*Defective Capacitor.
———————————————————————
Circuit Breaker *Defective load.
Trips *Defective receptacle.
*Excessive Load.
———————————————————————
Voltage too high *Engine speed is too high.
———————————————————————
Generator *Overloaded.
overheating *Insufficient ventilation.
———————————————————————
No output voltage *Short in load (disconnect).
*Tripped or defective circuit
breaker.
*Broken or loose wire.
*Defective receptacle.
*No residual magnetism
(in generator).
*Defective stator.
*Defective rotor (field).
*Shorted capacitor.
*Shorted diodes on rotor.
*GFCI Receptacle tripped.
———————————————————————
SPECIFICATIONS
WC5000H/D
Generator manufacturer WINCO Inc
Part number 15041-005
Rotor resistance 1.00 Ohms
Stator resistance G1-N. 0.18 Ohms
Stator resistance G3-N 0.35 Ohms
Cap winding resistance 0.54 Ohms
Capacitors 40.0 mF
Capacitor part number 15051-000
Engine manufacturer HONDA
Engine model number GX70R
Type R1VW1
Spark plugs BPR6ES (NGK)
Air filter 17211-ZE2-000
Spark plug gap 0.030 in
Oil capacity 1. qts.
SPECIFICATIONS
WC6000H/D & WC6000HE/D
Generator manufacturer WINCO Inc
Part number 1553-006
Rotor resistance 11.5 Ohms
Stator resistance G1-N 0.10 Ohms
Stator resistance G3-N 0.18 Ohms
Cap winding resistance 0.80 Ohms
Capacitors 40.0 mF
Capacitor part number 15051-000
Engine manufacturer HONDA
Engine model number GX340
Type RECOIL RT1VDE
ELECTRIC RTVWE
Spark plugs BPR6ES (NGK)
Air filter 17211-899-000
Spark plug gap 0.030 in
Oil capacity 1. qts.