Allen Sports AST200 - Manual (Page 3)

INSTRUCTIONAL
OWNER’S MANUAL
p
3
TRAILER ASSEMBLY & OPERATING INSTRUCTIONS
STEP 1:
STEP 2:
STEP 3:
STEP 4:
NOTE:
WARNING!: The spring-release pins must be engaged for safe operation of the trailer. Failure to Assemble
properly may result in injury. If the spring-release pins do not engage properly, DO NOT USE.
Call the customer service number as indicated in the attached literature for assembly assistance.
Remove the trailer from the box and check contents against the parts list.
NOTE(S): 1. Lay the trailer on the ground with the black fabric side down.
2. Set Walking Kit aside, as you will install this later.
3. Do not remove the white foam from the wheel axles until STEP 4
Raise the two side frame panels of the trailer. Remove the wheels, top cover, and flag from the trailer seating area.
Set these aside, you will install later.
Raise the crossbar into place until the hole on the side frame panel and the hole in the cross bar are lined up.
Insert the knob through the side frame panel and into the crossbar. Tighten the knob.
Knob will be attached to trailer frame with lanyard
WHEEL INSTALLATION
WARNING! Remove the foam from the wheel axles and discard immediately. Do not remove washers.
STEP 1:
STEP 2:
STEP 3:
STEP 4:
NOTE:
Lift the trailer back so the right side is up, and locate the right wheel.
Install the wheel axle by sliding the axle completely through the bracket
in the frame as shown.
Insert the Quick Release Pin (tethered to the trailer frame near the wheel bracket)
through the hole in the axle and lock the clip to secure the pin.
Repeat for the left wheel. When complete, give each of the wheels a tug to be sure
that they are secure.
Wheels must be properly installed with quick release pins closed and snapped
shut. If QR pins are not correctly attached, wheels may fall off. Do not use if QR
pins are missing, or if the closure is damaged or missing.
WARNING!: Check wheels periodically during and before each use to be sure that they have not
become loose. Failure to do so could result in SERIOUS INJURY to you or trailer’s occupants.