Two Brothers Racing Suzuki SV-1000 - Manual

Two Brothers Racing
Juice Box™ - Fuel Controller
2005-08 Suzuki SV1000 Installation & Operation Manual
Part # 008-102
Parts Incuded
Installation Instructions
Qty. Description Part Number
1 Juice Box™ Fuel Control Kit 008-102
3 Zip Ties
1 Adhesive Velcro Square
V.A.L.E.
V a r i a b l e a x i s l o c k i n g e x h a u s t
TM
Route the harness down the RH frame. connect ground to
the negative post of the battery. (Fig 5)
Route harness over rear cylinder head and down the left
side of the throttle body. (Fig 6)
Locate the throttle body harness connector, it’s between
the LH frame and airbox. Reach in through the LH frame
opening, find and disconnect. Pull the JUICE BOX™
harness connector out through the frame opening.
Connect the JUICE BOX™ harness to the throttle body
harness. Connect the JUICE BOX™ harness to the main
harness. Place a screwdriver on the back of the connector
(Fig 7) to hold it. Reach in through the frame opening and
connect the JUICE BOX™. (Fig 8)
6.
7.
8.
9.
IMPORTANT - PLEASE READ CAREFULLY
Warranty
two brothers racing warrants that this product carries a warranty for 2 years from date of purchase against original
defects in materials and workmanship. should this product fail to perform for either of the above reasons, two brothers
racing will repair or replace it with an equivalent product at no charge, except for postage, to the original retail purchaser.
to obtain the benefits of this warranty, the retail purchaser must return the product and proof of purchase to the place of
original purchase.
We recommend that this performance part be installed by a qualified motorcycle
technician. If you have any doubts as to your ability to install this performance part,
please consult with your local motorcycle dealer. Read all instructions first before
starting installation. Make sure the vehicle and exhaust system are completely cool
before starting the installation. Also, make sure the vehicle is secure during installation.
Be sure to save all stock components for possible use later.
The Juice Box™ is legal ONLY for closed course race vehicles. The Juice Box™ is not
applicable, nor inteded for use on EMISSIONS CONTROLLED street, highway or off-road
vehicles. The Juice Box™ is not applicable, nor inteded for use on aircraft.
Thank you for purchasing a genuine Two Brothers Racing
JUICE BOX™. This product represents a radical step
forward in tuning fuel-injected motorcycles and ATVs for
optimal performance using “load-based” technology.
We at Two Brothers Racing hope that you will find this
development as exciting and useful as we do. And
remember: Proper Fuel = Maximum Power!
Make sure the vehicle is completely cool before starting
the installation. Also, make sure the vehicle is secure and
will not roll around.
Remove side panel screws, side panels. (Fig 1)
Remove seat mount hardware, seat. (Fig 2)
Remove front tank mount hardware, lift and support tank.
(Fig 3)
Locate JUICE BOX™ in the tail section. (Fig 4)
1.
2.
3.
4.
5.
Continued on page 2
Fig 1
Fig 5
Fig 2
Fig 3
Fig 4
Fig 6
Fig 7
Fig 8