S&S Cycle 49-State EPA Certified Engines - Manual (Page 8)

10- Troubleshooting Tips
A- Engine will not start:
I- Fuel tank may be empty or petcock may be in closed position.
II- Weak or no-spark condition may be caused by a discharged battery, damaged ignition module, or damaged coil. Verify the condition
of components.
III- Spark plug gap may be too wide.
B- Engine will not run at steady speed or rpm:
I- There may be a restriction in fuel supply system (gas tank vent plugged, needle and seat not working properly, etc.)
II- Faulty ignition system. Check for fouled plugs, defective coil, defective electronic module, or improper ignition timing.
GENERAL INFORMATION NOTE: When the motorcycle is not running, the petcock should always be turned off to prevent possible fuel leakage past the
needle and seat.
CONCLUSION
Complete remainder of installation according to the applicable service manuals. Refer to the S&S® 49-State EPA Certified Engine Owner’s Manual for
important information on breaking in the engine.
V124E Specifications
Maximum N/V Ratio 43.3
Maximum Vehicle Weight 1058 lb (480 kg)
Exhaust Backpressure
Maximum 9.5" H20
Minimum 4.7" H20
V111E Specifications
Maximum N/V Ratio 43.3
Maximum Vehicle Weight 1058 lb (480 kg)
Exhaust Backpressure
Maximum 9.5" H20
Minimum 4.7" H20
V96E Specifications
Maximum N/V Ratio 43.3
Maximum Vehicle Weight 992 lb (450 kg)
Exhaust Backpressure
Maximum 5.0" H20
Minimum 0.6" H20
V89E Specifications
Maximum N/V Ratio 43.3
Maximum Vehicle Weight 992 lb (450 kg)
Exhaust Backpressure
Maximum 5.0" H20
Minimum 0.6" H20
V80E Specifications
Maximum N/V Ratio 43.3
Maximum Vehicle Weight 992 lb (450 kg)
Exhaust Backpressure
Maximum 5.0" H20
Minimum 0.6" H20
V117E Specifications
Maximum N/V Ratio 43.3
Maximum Vehicle Weight 1058 lb (480 kg)
Exhaust Backpressure
Maximum 9.5" H20
Minimum 4.7" H20
V93E Specifications
Maximum N/V Ratio 43.3
Maximum Vehicle Weight 992 lb (450 kg)
Exhaust Backpressure
Maximum 5.0" H20
Minimum 0.6" H20
V88E Specifications
Maximum N/V Ratio 43.3
Maximum Vehicle Weight 992 lb (450 kg)
Exhaust Backpressure
Maximum 5.0" H20
Minimum 0.6" H20
V79E Specifications
Maximum N/V Ratio 43.3
Maximum Vehicle Weight 992 lb (450 kg)
Exhaust Backpressure
Maximum 5.0" H20
Minimum 0.6" H20
ENGINE SPECIFICATIONS