JLG 601S ANSI Parts Manual - Manual (Page 121)

3120747 601S 2-75
SECTION 2 TURNTABLE
194 0181979 1 Angle, Seal Mount
195 3520060 1 Plug, Hole 3/8” (Not Shown)
196 3520035 1 Plug, Hole 1 1/2” (Not Shown) (S/N 58209 to S/N 74800)
197 3520033 1 Plug, Hole 1” (Not Shown) (S/N 58209 to S/N 74800)
198 0100010 A/R Adhesive (Not Shown) (S/N 58209 to S/N 74800)
199 3520054 4 Plug, Hole 7/16” (Not Shown)
200 3520034 4 Plug, Hole 5/16” (Not Shown)
201 3520085 1 Plug, Hole 9/16” (Not Shown)
202 1340061 1 Cleaner, Air Pre-Cleaner
203 3960511 1 Seal, Foam 1 3/4” x 1 1/4” x 28 3/4”
204 4922385 1 Harness, Air Flow (Not Shown)
205 0100048 A/R Grease Dielectric
206 1670836 4 Cover (S/N 74800 to Present)
Ref. ENGINE COMPONENTS
Ref. Engine - Ford LRG-425 Options:
2000166 Ref. S/N 58209 to S/N 60188
2000174 Ref. S/N 60188 to S/N 71583
2000193 Ref. S/N 71583 to Present
301 Use 3600377 1 Fuel Pump & Isolator Assembly (was p/n 7022133)
7022134 1 Harness, Fuel Pump Wiring
302 Use 91083218 1 Filter, Fuel (was p/n 7022135)
303 7019986 1 Starter (Not Shown)
304 7019977 1 Alternator with Pulley & Regulator
7000897 1 Alternator without Pulley & Regulator
305 7022136 1 Actuator, Throttle (S/N 58209 to S/N 62045)
7023655 1 Actuator, Throttle (S/N 62045 to S/N 71583)
7023683 1 Actuator, Throttle (S/N 71583 to Present)
7023652 1 Plate, Actuator Adapter (2000174/2000193 Engine Only)
7023654 1 Gasket, Actuator to Adapter Plate (2000174/2000193 Engine
Only)
7023653 2 Bolt (Adapter Plate to Intake Manifold) (2000174/2000193
Engine Only)
7023656 4 Bolt (Actuator to Adapter Plate) (2000174/2000193 Engine
Only)
306 7019996 1 Sensor, Air Temperature (S/N 58209 to S/N 62045)
Use 7019996 1 Sensor, Air Temperature (S/N 62045 to Present) (was p/n
7023661)
7023662 1 Bracket, Air Temperature Sensor
307 7022137 1 Harness, ECM (2000166 Engines)
7023663 1 Harness, ECM (2000174 Engines)
7023681 1 Harness, EPM (2000193 Engines)
308 7022139 1 Sensor, MAP
309 7019994 1 Sensor, EGR (S/N 58209 to S/N 71583)
7023682 1 Sensor, EGR (S/N 71583 to Present)
310 2420187 1 Dipstick
4564281 1 Tube, Dipstick (was p/n 7022146)
311 2720341 1 Horn, Rubber Air
312 7022142 1 Switch, Oil Pressure
FIGURE 2-15. FORD ENGINE INSTALLATION - LRG425 WITH EFI (S/N 58209 TO PRESENT)
ITEM # PART NUMBER QTY. DESCRIPTION REV.