Blodgett KTT-DS Series - Manual (Page 3)

OM-KTT-DS 1
IMPORTANT - READ FIRST - IMPORTANT
CAUTION: BE SURE ALL OPERATORS READ, UNDERSTAND AND FOLLOW THE OPERATING
INSTRUCTIONS, CAUTIONS, AND SAFETY INSTRUCTIONS CONTAINED IN THIS MANUAL.
WARNING: THIS UNIT IS INTENDED FOR USE IN THE COMMERCIAL HEATING, COOKING AND HOLDING OF
WATER AND FOOD PRODUCTS, PER THE INSTRUCTIONS CONTAINED IN THIS MANUAL. ANY
OTHER USE COULD RESULT IN SERIOUS PERSONAL INjURY OR DAMAGE TO THE EqUIPMENT
AND WILL vOID WARRANTY.
WARNING: KETTLES MUST BE INSTALLED BY PERSONNEL qUALIFIED TO WORK WITH STEAM PLUMBING.
IMPROPER INSTALLATION CAN RESULT IN INjURY TO PERSONNEL AND/OR DAMAGE TO
EqUIPMENT.
WARNING: AvOID ANY EXPOSURE TO ESCAPING STEAM. STEAM CAN CAUSE SEvERE BURNS.
WARNING: TAKE EXTREME CARE TO KEEP HOT CONTENTS FROM SPILLING OR SPLASHING ON ANYONE.
DO NOT STAND DIRECTLY IN FRONT OF KETTLE BODIES WHEN THEY ARE BEING TILTED.
WARNING: AvOID ALL DIRECT CONTACT WITH HOT EqUIPMENT SURFACES. DIRECT SKIN CONTACT
COULD RESULT IN SEvERE BURNS.
WARNING: AvOID ALL DIRECT CONTACT WITH HOT FOOD OR WATER IN KETTLES. DIRECT CONTACT
COULD RESULT IN SEvERE BURNS.
CAUTION: DO NOT OvER FILL THE KETTLE WHEN COOKING, HOLDING OR CLEANING. KEEP LIqUIDS
AT A MINIMUM OF 2-3” (5-8 CM) BELOW THE KETTLE BODY RIM TO ALLOW CLEARANCE FOR
STIRRING, BOILING AND SAFE PRODUCT TRANSFER.
WARNING: TAKE SPECIAL CARE TO AvOID CONTACT WITH HOT KETTLE BODY OR HOT PRODUCT WHEN
ADDING INGREDIENTS, STIRRING OR TRANSFERRING PRODUCT TO ANOTHER CONTAINER.
WARNING: WHEN TILTING KETTLE FOR PRODUCT TRANSFER:
1) WEAR PROTECTIvE OvEN MITT AND PROTECTIvE APRON.
2) USE CONTAINER DEEP ENOUGH TO CONTAIN AND MINIMIZE PRODUCT SPLASHING.
3) PLACE CONTAINER ON STABLE, FLAT SURFACE, AS CLOSE TO KETTLE AS POSSIBLE.
4) STAND TO LEFT OR RIGHT SIDE OF KETTLE (DEPENDING ON TILTING HANDLE PLACEMENT)
WHILE POURING. DO NOT STAND DIRECTLY IN POUR PATH OF HOT CONTENTS.
5) POUR SLOWLY, MAINTAIN CONTROL OF KETTLE BODY HANDLE AT ALL TIMES, AND
RETURN KETTLE BODY TO UPRIGHT POSITION AFTER CONTAINER IS FILLED OR TRANSFER IS
COMPLETE.
6) DO NOT OvER FILL CONTAINER. AvOID DIRECT SKIN CONTACT WITH HOT CONTAINER AND
ITS CONTENTS.
CAUTION: KEEP FLOORS IN FRONT OF KETTLE WORK AREA CLEAN AND DRY. IF SPILLS OCCUR, CLEAN
IMMEDIATELY TO AvOID SLIPS OR FALLS.
WARNING: FAILURE TO CHECK SAFETY vALvE OPERATION PERIODICALLY COULD RESULT IN PERSONAL
INjURY AND/OR DAMAGE TO EqUIPMENT.
WARNING: WHEN TESTING, AvOID AND EXPOSURE TO THE STEAM BLOWING OUT OF THE SAFETY vALvE.
DIRECT CONTACT COULD RESULT IN SEvERE BURNS.